SuzukiSavage.com - I think I may have a short.

zombeh_king YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 19	I think I may have a short. 08/26/16 at 19:23:51 It rained heavy the last few days and unfortunately I had nowhere to put my bike. I go to start it up and no lights no nothing. I've charged the battery and still zip. I'm new to bikes in general and I have no clue where to look. I can't find any normal style Fuses either.
Back to top	IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: I think I may have a short. Reply #1 - 08/26/16 at 19:27:22 Have you done anything to it lately? The fuses are under the edge of the seat, under the right thigh. Seat can stay on. If they are okay you need to check the battery voltage.
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

zombeh_king YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 19	Re: I think I may have a short. Reply #2 - 08/26/16 at 19:35:19 Found the fuse box and they are both not popped. :/
Back to top	IP Logged

zombeh_king YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 19	Re: I think I may have a short. Reply #3 - 08/26/16 at 19:36:40 The only thing I've done is take the tank off and the seat to check my wires. Any other fault points I should check?
Back to top	IP Logged

Armen Serious Thumper Offline Half-Witted Wrench-Jockey from Jersey Posts: 1431	Re: I think I may have a short. Reply #4 - 08/26/16 at 19:45:37 Loose and or dirty connections on the battery and the starter solenoid.
Back to top	In theory, theory and reality are the same. In reality, they aren't... IP Logged

zombeh_king YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 19	Re: I think I may have a short. Reply #5 - 08/26/16 at 19:46:52 I cleaned thoes up when I took the battery out to charge it. No corrosion.
Back to top	IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: I think I may have a short. Reply #6 - 08/26/16 at 19:49:51 The connectors under the tank can Do what you are experiencing. Take them apart, inspect, Then check battery voltage No reason to put the tank on till it's going.
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

Armen

Serious Thumper

Offline

Half-Witted
Wrench-Jockey from
Jersey

Posts: 1431

Re: I think I may have a short.
Reply #7 - 08/27/16 at 04:40:11

A simple 12V test light is your friend.
Start at the battery with a meter. Do you have over 12V?
Test light from + at battery to the engine. Light? Ground lead OK.
Put the alligator clip on the - terminal.
Start working your way downstream with the test light. Go to the start solenoid, to the key switch, 'switched' side of key switch, fuse panel.
Somewhere or other you'll stop seeing the light go on.

Back to top

In theory, theory and reality are the same. In reality, they aren't...

IP Logged

stewmills

Serious Thumper

Offline

Imagination is more
important than
knowledge

Posts: 2627
Auburn, AL
Gender: male

Re: I think I may have a short.
Reply #8 - 08/27/16 at 05:58:29

While you are pulling connectors apart it is a good time to put some dielectric grease on the connectors to semi waterproof and prevent future corrosion.

Make sure your key switch and handlebar kill switch are dried out and water isn't sitting in there shorting the circuit. Hair dryer on low can help. But don't cook or overheat things.

Back to top

IP Logged

justin_o_guy2

Serious Thumper

Offline

What happened?

Posts: 55279
East Texas, 1/2 dallas/la.

Re: I think I may have a short.
Reply #9 - 08/27/16 at 07:27:09

If it's just Totally Dead, no lights, no clicks, zip, zero, nada, nuttin,, and the fuses are good, I'd be checking out the connections under the tank and the battery.
If those are good then chasing the power is next.

Half split it as much as you can. Go about halfway to a place where you know power is supposed to be, see if it's even there. If so, move on down, if not, move back.

Once you start Thinking about it right it's not so terrifying.

Back to top

The people never give up their liberties but under some delusion.- Edmund Burke.

IP Logged

batman Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 3806 osceola new york Gender:	Re: I think I may have a short. Reply #10 - 08/27/16 at 16:04:29 Fuses can look good but pull and check with a meter,check the ground wire from the battery to where it bolts to the rear of the engine case ,are they clean and tight? no ground, no show!
Back to top	my old work mates called me MacGyver IP Logged

zombeh_king YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 19	Re: I think I may have a short. Reply #11 - 08/27/16 at 16:17:01 Replaced the Fuses and no dice. I ran it over with my multimeter and I'm pulling from 10 to 14v at various locations. I'm thinking it could be my rectifier or my stator but I'm not sure.
Back to top	IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: I think I may have a short. Reply #12 - 08/27/16 at 21:42:00 How does the rectifier affect your starter? The stator? Just something to say? Will the horn work? Got lights? What's the voltage at the battery? Does anything happen when you hit the Start button? What is the battery voltage WHILE the Start button is pushed?
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

zombeh_king YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 19	Re: I think I may have a short. Reply #13 - 08/27/16 at 21:56:29 No electronics function but they still have voltage from what I've tested running through the wire harness with a multimeter. The battery only dips if it is in the on or park position.
Back to top	IP Logged

zombeh_king YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 19	Re: I think I may have a short. Reply #14 - 08/27/16 at 21:58:01 The voltage is 12.7 then drops to 6.8 in the on position and goes back to the original 12.7 in the off position.
Back to top	IP Logged