SuzukiSavage.com - More throttle = less fuel

Eegore

Serious Thumper

Offline

SuzukiSavage.com
Rocks!

Posts: 8376

More throttle = less fuel
03/01/23 at 13:34:51

I tried searching for this but didn't find anything specific to my issue even though I am sure it exists here somewhere:

1995 with Raptor petcock, stock carb, and throttle assembly.

It starts fine and idles, but when throttle is applied, in neutral, the bike dies. Essentially more throttle twist equals less fuel. There is no difference if the choke is pulled out all the way. I noticed it likes to slip back into the intermediary position so a choke replacement might be in order.

I assume this is a carb issue, but I'd like to make an order of operations. The petcock is clear, fuel is flowing, so do I work my way to the airbox/filter or just go into the carb first?

Back to top

IP Logged

Gary_in_NJ Serious Thumper Offline LS650 Cafe Racer Posts: 2633 Amongst the Twisty Roads	Re: More throttle = less fuel Reply #1 - 03/01/23 at 14:28:58 I suspect that you either have a clogged jet, or the diaphragm in the upper chamber is cracked or not properly seated.
Back to top	A life-time student of motorcycling. LS650 Cafe, DRZ400SM, FZ6N, SV650S, CB900C, Ducati ST2, CB550F-SS My LS650=> http://suzukisavage.com/yabb2.2/Attachments/Left.JPG IP Logged

Ruttly Serious Thumper Offline Thumpers Rule Posts: 5113 Manteca , CA Gender:	Re: More throttle = less fuel Reply #2 - 03/01/23 at 16:08:42 Change that air filter lately ? Are you running a fuel filter ? Fuel is flowing. If it’s not any of those then carb is dirty and needs blown out. Stock carb it could be a massive vacuum leak too ! Big fun .
Back to top	The Topic Terminator IP Logged

Eegore Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 8376	Re: More throttle = less fuel Reply #3 - 03/01/23 at 18:52:35 Air filter is clean, no in-line fuel filter. Looks like I am doing some carb checks next. I'm pretty sure I have a Mikuni sitting around somewhere so maybe I should just try to put that in. Thanks for the input.
Back to top	IP Logged

verslagen1 YaBB Moderator ModSquad Offline Where there's a will, I want to be in it. Posts: 28890 L.A. California Gender:	Re: More throttle = less fuel Reply #4 - 03/01/23 at 21:21:03 Most likely clogged main jet but I think I had the same symptoms with bad float ht. if it were a bad diaphragm, it just wouldn't accelerate, not up and die.
Back to top	Versey's Place Tech Section Index IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: More throttle = less fuel Reply #5 - 03/02/23 at 04:10:45 Sitting, idling, all good,a twist on the stick and it just Dies? I've seen that happen with old gas,, If it's old gas, it's easy to swap out. Otherwise, as has been noted, if it was the petcock it wouldn't die. If you can drop the bowl you can access the jets.
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

Eegore Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 8376	Re: More throttle = less fuel Reply #6 - 03/02/23 at 05:19:18 Sitting, idling, all good,a twist on the stick and it just Dies? I've seen that happen with old gas,, I'm not sure when this bike was ridden last, I had not considered the gas. I will have it drained and replaced.
Back to top	IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: More throttle = less fuel Reply #7 - 03/02/23 at 05:50:16 Good luck,,Let us know
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

pg Serious Thumper Offline Posts: 5273 In Transit	Re: More throttle = less fuel Reply #8 - 03/02/23 at 06:10:47 If you leave ethanol gas in there to long, it can gum up the carb as well. I won't put that stuff anymore. Best regards,
Back to top	I don't make the rules, I just know what they are..... IP Logged

LANCER Serious Thumper Alliance Member Offline Savage Beast Performance Parts Posts: 10671 Oklahoma Gender:	Re: More throttle = less fuel Reply #9 - 03/02/23 at 11:38:06 There are some NASTY carbs out there. 😷 Colors and consistencies normally associated with refuse.
Back to top	IP Logged

ohiomoto

Serious Thumper

Offline

SuzukiSavage.com
Rocks!

Posts: 2778

Re: More throttle = less fuel
Reply #10 - 03/02/23 at 19:27:38

My bike had a worn and sticky slide a few years back and acted as you described. One time it wouldn't go over 20 mph in any gear. I cleaned it up and it worked well for a while.

Later that summer it stuck hug up again on a gear shift and it went from 45 to 20 in a hurry. It limped along for a few seconds before it freed up and went back to normal.

I purchased a replacement slide it's been problem free ever since. If the black coating is worn off and sticking to the body of the carb it is time to get a new one.

Back to top

IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: More throttle = less fuel Reply #11 - 03/02/23 at 19:41:55 How many miles on it?
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

Eegore Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 8376	Re: More throttle = less fuel Reply #12 - 03/02/23 at 19:55:09 "How many miles on it?" I'm not sure, I am not near it but I'd say around 20k.
Back to top	IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: More throttle = less fuel Reply #13 - 03/02/23 at 21:36:50 Doesn't sound like enough miles to have worn the slide,unless it was subjected to a buncha dirt,enough to get through the air filter. It's not one of those bikes that got a few miles being dragged, is it?
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

Eegore Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 8376	Re: More throttle = less fuel Reply #14 - 03/03/23 at 09:19:34 Nah the drag and drop was a one-time deal. It was a Harley anyway, we needed the weight.
Back to top	IP Logged