SuzukiSavage.com - Is my oil pump broken?

Welcome, Guest. Please Login or Register :: View Members

SuzukiSavage.com › General Category › Rubber Side Down! › Is my oil pump broken?

(Moderators: verslagen1, Dave, Serowbot)

‹ Previous topic | Next topic ›

Pages: 1

Is my oil pump broken? (Read 86 times)

kojones Full Member Offline SuzukiSavage.com Rocks! Posts: 223 Finland	Is my oil pump broken? 05/03/17 at 04:51:48 Been trying to figure out why my bike makes weird intermittent tapping https://www.dropbox.com/s/l3g5urqij0keuxs/2017-05-03%2014.46.12.mov?dl=0 Time to split the case and replace the oil pump?
Back to top	« Last Edit: 05/03/17 at 14:14:45 by kojones » IP Logged

kojones Full Member Offline SuzukiSavage.com Rocks! Posts: 223 Finland	Re: Is my oil pump broken? Reply #1 - 05/03/17 at 05:47:01 I fixed it with a thin washer under the lock ring, pump seems to work but think I'll have to wash it thoroughly by pumping some oil through and then check my oil pressure. Hope this will get rid of the noise. Think that sprocket was the other way around...
Back to top	2017-05-03_15_56_55.jpg « Last Edit: 05/03/17 at 14:35:47 by kojones » IP Logged

kojones Full Member Offline SuzukiSavage.com Rocks! Posts: 223 Finland	Re: Is my oil pump broken? Reply #2 - 05/03/17 at 11:18:01 Oil flows to camshaft very well by cranking with the starter motor, so no need to replace the oil pump just because a lots of axial clearance. Still no help to my engine noise
Back to top	IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: Is my oil pump broken? Reply #3 - 05/03/17 at 13:58:45 Miles, any mods, any maintenance done, when did it start, what makes it worse, better, Details.
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

kojones Full Member Offline SuzukiSavage.com Rocks! Posts: 223 Finland	Re: Is my oil pump broken? Reply #4 - 05/03/17 at 14:12:30 justin_o_guy2 wrote on 05/03/17 at 13:58:45: Miles, any mods, any maintenance done, when did it start, what makes it worse, better, Details. More info about the noise and the bike can be found here: http://suzukisavage.com/cgi-bin/YaBB.pl?num=1462709066 At least the oil pump is fine
Back to top	IP Logged

verslagen1

YaBB Moderator
ModSquad

Offline

Where there's a
will, I want to be
in it.

Posts: 28884
L.A. California
Gender: male

Re: Is my oil pump broken?
Reply #5 - 05/03/17 at 14:47:00

kojones wrote on 05/03/17 at 05:47:01:

Hope this will get rid of the noise. Think that sprocket was the other way around...

The sprocket should mostly align with the gear behind the clutch, less than half and one or the other is backwards and will disengage.

If adding a washer to that gear resolved the tapping, I would think that it's loose on the shaft and would replace it.

Versey's Place
Tech Section Index

IP Logged

Pages: 1

‹ Previous topic | Next topic ›

« Home