Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Bike dies at lights or won't shift into 1st.
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages:
1
2
Bike dies at lights or won't shift into 1st. (Read 208 times)
Kruzader
Full Member
Offline
SuzukiSavage.com
Rocks!
Posts: 129
Stockon, CA
Gender:
Re: Bike dies at lights or won't shift into 1st.
Reply #15 -
01/31/17 at 00:12:12
savagebruh wrote
on 01/30/17 at 11:51:21:
darn well I hope I haven't kicked that thing too hard to break it. I'll check it out. It seems like I should check the petcock for sure and or adjust the idle speed. I have zero tools and know how so we'll see how it goes. 😅
Like you, I am not that moto mech savvy, but with the help of other members and around $50 dollars, I fixed my bike from turning off at stops or around first gear.
For tools all you need is a philp screw driver, some pliers, a utility knife.
Screw driver to detach the petcock, pliers for the clamps, and a utility knife to cut the hose. OH YEA and 2 minor things, a container to drain the gas tank (before you even start anything)...and the rubber cap to close a piece of the carburator.
http://suzukisavage.com/cgi-bin/YaBB.pl?num=1315418285
Back to top
When you need something and have limited resources be creative.
2005 Boulevard S40 - Elevation 13'
IP Logged
savagebruh
YaBB Newbies
Offline
SuzukiSavage.com
Rocks!
Posts: 8
Re: Bike dies at lights or won't shift into 1st.
Reply #16 -
01/31/17 at 00:32:05
I didn't rejet the carb. I have noticed too since I changed the exhaust it pops a lot more which I figured was from not re jetting. I didn't know it could be contributing too the engine dying too.
Glad to know someone else with little experience has been able to fix this same problem. Thanks for the advice, makes me feel less intimidated.
Back to top
IP Logged
batman
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 3806
osceola new york
Gender:
Re: Bike dies at lights or won't shift into 1st.
Reply #17 -
01/31/17 at 10:11:45
You might want to revisit your muffler install ,an air leak where the muffler and exhaust pipe meet can cause increased popping.
Back to top
my old work mates called me MacGyver
IP Logged
HAPPYDAN
Senior Member
Offline
SuzukiSavage.com
Rocks!
Posts: 270
Re: Bike dies at lights or won't shift into 1st.
Reply #18 -
01/31/17 at 10:40:34
I didn't see it, but did anyone mention the clutch may need some adjustment? I had a hard shifting problem awhile back, and it just needed a little clutch adjustment. I guess, like anything else that moves, the plates wear a little over time, cables stretch, etc. And I'll chime in on that petcock. It's been the source of many unhappy Savage riders. Put it on PRI and ride for awhile and see if that helps.
Back to top
IP Logged
justin_o_guy2
Serious Thumper
Offline
What happened?
Posts: 55279
East Texas, 1/2 dallas/la.
Re: Bike dies at lights or won't shift into 1st.
Reply #19 -
01/31/17 at 14:40:44
I don't understand why anyone would even wait. Unless you are just determined to have a vacuum operated petcock, and some just simply prefer it, knowing what the eventual result will be, but I bought a Raptor petcock about a week after I got the bike. I installed it when it was valve adjust time. It was leaking.
Versy, I think the spring inside the petcock would cut down and make a great spring for the Verslavy last mod. It's very flat on the ends.
Back to top
The people never give up their liberties but under some delusion.- Edmund Burke.
IP Logged
verslagen1
YaBB Moderator
ModSquad
Offline
Where there's a
will, I want to be
in it.
Posts: 28888
L.A. California
Gender:
Re: Bike dies at lights or won't shift into 1st.
Reply #20 -
01/31/17 at 15:17:45
justin_o_guy2 wrote
on 01/31/17 at 14:40:44:
Versy, I think the spring inside the petcock would cut down and make a great spring for the Verslavy last mod. It's very flat on the ends.
I have to check it out, got a couple sitting in a box doing nothing.
But I did find 1 that I want to check, found it in the plumbing section.
Back to top
Versey's Place
Tech Section Index
IP Logged
Pages:
1
2
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
10/01/24 at 15:44:19
›
General Category
›
Rubber Side Down!
› Bike dies at lights or won't shift into 1st.
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.