SuzukiSavage.com - Cranking Problems

Welcome, Guest. Please Login or Register :: View Members

SuzukiSavage.com › General Category › Rubber Side Down! › Cranking Problems

(Moderators: verslagen1, Dave, Serowbot)

‹ Previous topic | Next topic ›

Pages: 1 2 3 4

Cranking Problems (Read 427 times)

S-P Serious Thumper Offline Back in the saddle again Posts: 816 Phoenix, AZ Gender:	Re: Cranking Problems Reply #45 - 04/10/14 at 07:49:31 mhart731 wrote on 04/10/14 at 07:26:27: I think we found the problem. At TDC the rocker arms don't budge. Double check that you are on TDC on the correct stroke.
Back to top	IP Logged

oldNslow

Serious Thumper

Offline

SuzukiSavage.com
Rocks!

Posts: 2686
Rochester, NY
Gender: male

Re: Cranking Problems
Reply #46 - 04/10/14 at 08:25:55

S-P wrote on 04/10/14 at 07:49:31:

mhart731 wrote on 04/10/14 at 07:26:27:

I think we found the problem. At TDC the rocker arms don't budge.

Double check that you are on TDC on the correct stroke.

Amen to that. Roll the engine over several times and make sure that you never get to a place where the timing marks are lined up and BOTH rocker arms are free. If that turns out to be the case you're going to need a service manual I think. I don't know if anyone is going to be able to walk you through checking the valve timing by typing back and forth.

I'm making one assumption here - that you didn't try doing a valve adjustment when you were working on the bike prior to the not starting issue.

IP Logged

mhart731

YaBB Newbies

Offline

SuzukiSavage.com is
a lifeline..

Posts: 33
Jackson, TN
Gender: male

Re: Cranking Problems
Reply #47 - 04/10/14 at 09:48:56

Here's an update on my problem. I bypassed all safety switches, filled it with new gas. I made sure I was on TDC on compression stroke and set the valve clearances. Picked up a compression tester, it shows 130 psi. New spark plug and fully charged battery. I've got a couple of theories. Either some kind of electrical or relay, or maybe the starter. Here's a videos of starting attempts. One with choke and one without.

http://youtu.be/sJOIb-qGabM

« Last Edit: 05/09/14 at 13:51:06 by mhart731 »

IP Logged

mhart731 YaBB Newbies Offline SuzukiSavage.com is a lifeline.. Posts: 33 Jackson, TN Gender:	Re: Cranking Problems Reply #48 - 05/09/14 at 13:52:03 http://youtu.be/fK16dl5YEss
Back to top	IP Logged

Dave YaBB Moderator ModSquad Online SuzukiSavage.com Rocks! Posts: 18138 Camp Springs, Kentucky Gender:	Re: Cranking Problems Reply #49 - 05/09/14 at 13:59:05 That sounds an awful lot like a weak battery.....the neutral light is nearly going out when the engine hits top dead center. There may not be enough battery to run the spark right when you need it.
Back to top	Someday I will be old......But not today! IP Logged

old_rider Serious Thumper Offline Backyard Bill Productions Posts: 3147 flordia panhandle Gender:	Re: Cranking Problems Reply #50 - 05/09/14 at 14:18:11 Rectifier ? short or loose ground not allowing power on start? Leaky vacuum plug? guess I should go back and reread again....been awhile since I read the full post.
Back to top	We are here to laugh at the odds and live our lives so well that Death will tremble to take us. IP Logged

Pages: 1 2 3 4

‹ Previous topic | Next topic ›

« Home