Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Idle mixture screw strangeness
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages: 1
Idle mixture screw strangeness (Read 13 times)
LikeTheSoup
YaBB Newbies
Offline
SuzukiSavage.com
Rocks!
Posts: 2
Idle mixture screw strangeness
09/07/26 at 11:31:38
I went looking for the infamous 'EPA plug', and found that it had already been removed. It may be hard to see in this photo, but the idle mixture screw actually stands slightly proud of the hole, such that it looks like no plug could ever have been there. I wondered if this meant that my bike was running scandalously rich, so I counted the turns it took to fully seat the screw. I expected 4-5 turns, but it was only 1 3/4 turns! I then backed the screw back out to the original position and went further to 2 full turns out. This seems to have cleared up the tendency of the bike to die when I close the throttle abruptly. So, was she actually running a bit lean? Has anyone seen an idle mixture screw like this before?
Back to top
IdleMixtureScrew1.png
IP Logged
DragBikeMike
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 4744
Honolulu
Re: Idle mixture screw strangeness
Reply #1 -
09/07/26 at 14:10:01
"Has anyone seen an idle mixture screw like this before?"
Yes, you might have a bogus aftermarket mixture screw. These bogus screws make it close to impossible to correctly adjust the idle mixture. The tapered tip of the screw is too small so that it doesn't control fuel flow until the screw is almost completely seated. This old post will give you all the specifics.
http://suzukisavage.com/cgi-bin/YaBB.pl?num=1641171298
If you can't achieve satisfactory idle mixture, you can correct the issue by installing a genuine Suzuki mixture screw. Another option is the PUDA carb kit (if available). This old post provides the specifics on the PUDA kit. As I recall, the mixture screw in the PUDA kit also sits proud in the hole, but the geometry of the tapered tip is correct. It works good.
https://suzukisavage.com/cgi-bin/YaBB.pl?num=1750728203
Back to top
Knowledge is power.
IP Logged
Pages: 1
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
09/09/26 at 11:31:02
›
General Category
›
Rubber Side Down!
› Idle mixture screw strangeness
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.