SuzukiSavage.com - No start after dying mid-ride

Welcome, Guest. Please Login or Register :: View Members

SuzukiSavage.com › General Category › Rubber Side Down! › No start after dying mid-ride

(Moderators: verslagen1, Dave, Serowbot)

‹ Previous topic | Next topic ›

Pages: 1

No start after dying mid-ride (Read 26 times)

MilesCCTX

YaBB Newbies

Offline

SuzukiSavage.com
Rocks!

Posts: 1

No start after dying mid-ride
12/04/24 at 17:28:38

Was cruising about 45 mph when the bike started to lose power, i figured I had just run it out of gas. When i pull over to switch the petcock to reserve, I saw a lot of oil coming from what I believe is the head gasket, but i’m not 100% positive. Bike no longer starts, just keeps cranking over. I have verified that i’m getting fuel and spark, still need to check for compression but I wanted to see what you guys thought about it. I’ve looked through all the other topics on here on oil leaks and haven’t found anything relating to head gaskets or no start condition. I believe I also have a leak from the notorious head plug, but I’m still confused on why it just died on me.

Thanks, Miles

IP Logged

Yoshi

Serious Thumper

Offline

SuzukiSavage.com
Rocks!

Posts: 879
LongIsland, N.Y.
Gender: male

Re: No start after dying mid-ride
Reply #1 - 12/04/24 at 19:39:00

I see this is your first post so Welcome to the forum!

You say you verified that you have spark and fuel? Then it maybe compression is what you're missing, remember to disconnect the thing ontop of the motor that lifts the valves or you won't get a compression test.

I have seen head plugs leak but it shouldn't give you a no start issue.

Also check for fuel in you oil, maybe be a bad petcock

IP Logged

JOG Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 1485 Longview, Texas Gender:	Re: No start after dying mid-ride Reply #2 - 12/04/24 at 21:00:44 Spark with the plug out doesn't mean you have spark with it in. Compression loads the starter and eats power. If the battery isn't Hot,it will turn over and not spark. I like WD40 for a fuel. It's got lube,and it's got butane. Ether or any other flammable is okay, but they don't lube cylinder walls.
Back to top	IP Logged

ThumperPaul

Serious Thumper

Offline

SuzukiSavage.com
Rocks!

Posts: 1945
Houston, Texas
Gender: male

Re: No start after dying mid-ride
Reply #3 - 12/05/24 at 05:17:27

Can you share a pic of the oil leak?

The head plug leak will be most noticeable in the cavity next to the exhaust port. Look in that cavity and see if there is wet oil in there. Unless the plug has completely popped out, the usual nuance leak should not cause a no start condition (unless you’ve completely run out of oil).

http://suzukisavage.com/cgi-bin/YaBB.pl?num=1099227295

The head to head cover uses sealant (no gasket). That can leak. And the head cover bolt that protrudes into spark plug area can leak. Suzuki bored the hole a little too deep.

Sounds like a fuel delivery issue to me. Do you have a stock OEM petcock valve? Try putting it on prime and make sure you have at least 1 gallon of fuel in the tank. Put it on prime, remove the fuel line at the valve or carb, and see if gas pours out. It should flow pretty good. If you have a weak stream, replace the petcock valve or talk to your urologist. Huh

IP Logged

Pages: 1

‹ Previous topic | Next topic ›

« Home