SuzukiSavage.com - decel bogging noise

Welcome, Guest. Please Login or Register :: View Members

SuzukiSavage.com › General Category › Rubber Side Down! › decel bogging noise

(Moderators: verslagen1, Dave, Serowbot)

‹ Previous topic | Next topic ›

Pages: 1

decel bogging noise (Read 70 times)

seve321

Junior Member

Offline

SuzukiSavage.com
Rocks!

Posts: 55

decel bogging noise
04/13/18 at 19:53:48

My bike one day just started to make a lot of noise and backfiring. I have 155 main jet and a 52.5 pilot jet. I've had this set up for a while and never had all the noise before. I've messed with the air/fuel mixture screw and the pilot jet and I can't get it to let up. Also I noticed the owner before me cut the spring for the little diaphragm near the air/fuel mix screw (I don't what its called). Not sure if that affected it much. do I need to change the jets? Btw I'm at about 650 elevation.

IP Logged

Dave YaBB Moderator ModSquad Offline SuzukiSavage.com Rocks! Posts: 18104 Camp Springs, Kentucky Gender:	Re: decel bogging noise Reply #1 - 04/13/18 at 20:02:09 It could be an air leak....have you check to see if the carb manifold is cracked and the bolts are tight? As the rubber ages, sometimes they crack and create an air leak.
Back to top	Someday I will be old......But not today! IP Logged

DragBikeMike Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 4406 Honolulu	Re: decel bogging noise Reply #2 - 04/13/18 at 23:17:58 It might also be that the little diaphragm that you mentioned has failed. Do a thorough visual inspection. Hold it up to a light and see if there are any holes or tears. That diaphragm is part of a system intended to surpress the afterfire that you describe.
Back to top	Knowledge is power. IP Logged

batman Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 3806 osceola new york Gender:	Re: decel bogging noise Reply #3 - 04/14/18 at 08:18:52 DBM,is right the TEV valve adds extra fuel when the throttle is closed. you should also check the tiny passage that sits behind the little "arm" on the diaphragm ,this is the place the vacuum comes from to open the valve it could be plugged. after firing can also be cause be air leaks in the exhaust.
Back to top	my old work mates called me MacGyver IP Logged

seve321 Junior Member Offline SuzukiSavage.com Rocks! Posts: 55	Re: decel bogging noise Reply #4 - 04/14/18 at 12:02:04 To check for sure leaks should I use soapy water and look for bubbles or is there another method?
Back to top	IP Logged

Dave YaBB Moderator ModSquad Offline SuzukiSavage.com Rocks! Posts: 18104 Camp Springs, Kentucky Gender:	Re: decel bogging noise Reply #5 - 04/14/18 at 13:02:12 With a warm engine idling.....take an unlit propane torch around the intake manifold, and listen for any change in idle speed.
Back to top	Someday I will be old......But not today! IP Logged

wordet11 Full Member Offline Posts: 112 Athens, Ohio	Re: decel bogging noise Reply #6 - 04/14/18 at 16:14:34 Could also be a failing petcock. When the stock petcock started to wear out on mine it did this same thing. The bike was running lean but the carb wasn't the issue. The petcock was restricting fuel flow.
Back to top	IP Logged

seve321 Junior Member Offline SuzukiSavage.com Rocks! Posts: 55	Re: decel bogging noise Reply #7 - 04/14/18 at 18:53:54 I checked the diaphragm and it looks like it has a little damage but it didn't look like any tears all the way through. I'll be checking for an air leak next.
Back to top	IP Logged

Dave

YaBB Moderator
ModSquad

Offline

SuzukiSavage.com
Rocks!

Posts: 18104
Camp Springs, Kentucky
Gender: male

Re: decel bogging noise
Reply #8 - 04/15/18 at 03:36:50

seve321 wrote on 04/14/18 at 18:53:54:

I checked the diaphragm and it looks like it has a little damage but it didn't look like any tears all the way through. I'll be checking for an air leak next.

If the diaphragm is stiff...it may be too stiff to work. I had to replace one of these diaphragms in a carb not long ago - rubber parts don't last forever.

Someday I will be old......But not today!

IP Logged

Pages: 1

‹ Previous topic | Next topic ›

« Home