Mitsy
YaBB Newbies
Offline
SuzukiSavage.com Rocks!
Posts: 15
|
Hello folks!
If been scouting on this forum for several weeks now, now its time to post something!
Year: 1992 Kilometers: 64000 Completely stock engine
So i purchased a Savage a while ago as starter bike, when i finally could drive it worked fine for some weeks. Now after a while going to work for somedays it started to run bad, it runs at very high rpm in idle, but giving a litle bit of gas and it goes back again to normal idle. And while driving and slowing down it sputters and it goes completely out at the stoplight. Also when i release the gas it jerks. I have to drive with the choke full out or else it wont run. Now i already had some problems with the carb before, the diaphgram was damaged so i bought a good 2nd hand carb and replaced the best parts to my own, it all worked fine and good and now this problem shows up. Carb is completely cleaned several times(even without finding any dirt). When i start it with the choke the rpms are not any different then when its warm, not even a lil bit higher. Last time i removed the carb because i couldnt drive faster and it was super slow, i found that the diaphgram was stuck at the sides so i sanded the rough edges a lil bit with 1200, doesnt sound good but it was scratched from the inside. The petcock is good, carb is clean, it gets enough fuel, air screw is at 1.5 open. Fresh castrol oil 20w40 JASO MA2.
Also i could easily push the bike forward in 4th gear so i think that the valves arent good either.
This problem starts to happen when the engine gets warmer so i suspect there is something wrong with the choke, but i dont know what. If been to several dealers but they all dont wanna help me because its a savage This is my first bike so i do not know much about bikes at all, but i did what i could do.
Thanks in advance, and hope to hear something soon!
|