Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Bike quit for no apparent reason, any ideas?
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages: 1
Bike quit for no apparent reason, any ideas? (Read 137 times)
wiscoz88
YaBB Newbies
Offline
SuzukiSavage.com
Rocks!
Posts: 9
Wisconsin
Bike quit for no apparent reason, any ideas?
06/26/17 at 12:56:30
Started the morning out with no issues, got the bike warmed up and headed out to work. 20 minutes into the ride, I pulled up to a stoplight and my bike quickly idled down to nothing. I’d been sitting at a couple stoplights just before this and had no issue. No obvious answers that I could see – I didn’t bump the kill switch, fuel switch is set to ‘on’, bike has at least half a tank of gas…also the battery is only a few months old.
I pulled the choke all the way out, flipped the fuel switch to prime and tried to restart – tried turning over a couple times without success but I cranked the throttle on the third try and managed to get it back up and running. Once I got to work, I let it go back down to idle to see what happened, but it seemed to be back to normal. Idling sounded fine and it sat at least 30 seconds without quitting again (fuel switch set to 'on' and choke off). Hoping I can get some ideas on what might have happened, or where to start troubleshooting. Thanks!
Back to top
IP Logged
norm92de
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 1180
El Paso TX
Gender:
Re: Bike quit for no apparent reason, any ideas?
Reply #1 -
06/26/17 at 13:10:07
Wizcos,
If it were my bike I would install a genuine Yamaha raptor petcock.
They are cheap insurance. You can get the part #off this site but be sure not to get a Chinese knock off.
The Suzuki petcock is a funky device and will give trouble sooner or later. It may not be your problem but at least you will have eliminated the number one cause of fuel problems.
Back to top
2014 S40. Raptor. idle mixture adj.Needle raised one notch. 4000' altitude. Stock jets. Shell Rotella synthetic.
IP Logged
Dave
YaBB Moderator
ModSquad
Offline
SuzukiSavage.com
Rocks!
Posts: 18101
Camp Springs, Kentucky
Gender:
Re: Bike quit for no apparent reason, any ideas?
Reply #2 -
06/26/17 at 13:21:10
I don't believe I would have used the choke on a hot engine right off the bat.....I would have tried the PRI position without the choke first.
And you should probably put a golf tee and a proper sized vacuum cap in your tool kit - so you can bypass the stock vacuum petcock if it acts up and makes you stranded. (Remove the vacuum line, plug the line and the nipple, turn the petcock to PRI and you will be able to ride the bike home).
Back to top
Someday I will be old......But not today!
IP Logged
stewmills
Serious Thumper
Offline
Imagination is more
important than
knowledge
Posts: 2641
Auburn, AL
Gender:
Re: Bike quit for no apparent reason, any ideas?
Reply #3 -
06/26/17 at 13:31:38
The really important question is how long have you had the bike and have been riding it with no issue, and have you done ANY work to the bike, particularly the carb or air intake? Air/mix screw adjustments?
I recently had a carb issue where mine was dying at long idles and ended up diagnosing it as a rich mixture at idle due to a slightly high needle jet.
Do you see soot on your rear brake adjustment arm or see poofs of black smoke when it restarts after this happens? Soot/dark smoke is sign of rich mixture and flooding, but there is no guarantee it is the needle jet or pilot jet or air/mix screw without further diagnosis.
OR as others have noted it may simply be a petcock starting to fail.
Back to top
2008 | 152/52.5–Air Mix 3/4 | Rotella T4 | Seat Lift w/Sheepskin | Speedo Rattle | Rear Pulley Shim | 140/90-15 Rear | Kaw Front Pulley | Relocated Rear Signals
FREEDOM ISN'T FREE!
IP Logged
verslagen1
YaBB Moderator
ModSquad
Offline
Where there's a
will, I want to be
in it.
Posts: 28889
L.A. California
Gender:
Re: Bike quit for no apparent reason, any ideas?
Reply #4 -
06/26/17 at 14:51:14
Dave wrote
on 06/26/17 at 13:21:10:
I don't believe I would have used the choke on a hot engine right off the bat.....I would have tried the PRI position without the choke first.
YUP! and this is why you had to "cranked the throttle" to get to start... you flooded it.
Back to top
Versey's Place
Tech Section Index
IP Logged
jcstokes
Serious Thumper
Offline
SuzukiSavage.com is
very useful
Posts: 2119
Mauku New Zealand
Gender:
Re: Bike quit for no apparent reason, any ideas?
Reply #5 -
06/26/17 at 19:15:45
Perhaps look under the seat and the cover near the ignition switch for loose wires, chek the earth strap for tightness
Back to top
Completely stock 2010 S40, aftermarket rev counter and back pack, Airhawk seat pad
IP Logged
wiscoz88
YaBB Newbies
Offline
SuzukiSavage.com
Rocks!
Posts: 9
Wisconsin
Re: Bike quit for no apparent reason, any ideas?
Reply #6 -
06/29/17 at 08:42:56
Thanks for the info on the rookie mistake I made...
I probably should have mentioned that I did install the raptor petcock about three months ago, so can rule that out as being the cause. I've had the bike 3 years and other than what led to replacing the stock petcock, have had no issues. Haven’t touched the carb/air intake but would that be a good place to start?
Back to top
IP Logged
justin_o_guy2
Serious Thumper
Offline
What happened?
Posts: 55279
East Texas, 1/2 dallas/la.
Re: Bike quit for no apparent reason, any ideas?
Reply #7 -
06/29/17 at 09:43:52
Air filter
Back to top
The people never give up their liberties but under some delusion.- Edmund Burke.
IP Logged
batman
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 3806
osceola new york
Gender:
Re: Bike quit for no apparent reason, any ideas?
Reply #8 -
06/30/17 at 19:12:39
I f you've never done anthing to the bike (carb) your running the lean factory setting . ( it idled at the two stoplights before ) in city traffic? Maybe it was running hotter than normal and just stalled ,Maybe you should adjust the mix screw?rejet?
Back to top
my old work mates called me MacGyver
IP Logged
Serowbot
YaBB Moderator
ModSquad
Offline
OK.... so what's the
speed of dark?
Posts: 28674
Tucson Az
Gender:
Re: Bike quit for no apparent reason, any ideas?
Reply #9 -
07/01/17 at 05:49:03
Check the safety cut-outs...
You can bypass them with a jumper wire.
Clutch is at the handlebar lever, and sidestand connector is under the seat...
They are 2-wire connectors,.. just jumper the 2 wires together...
When these go bad, they cause intermittent stalls all over the place...
Back to top
Ludicrous Speed !... ...
...
IP Logged
Pages: 1
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
10/02/24 at 07:19:21
›
General Category
›
Rubber Side Down!
› Bike quit for no apparent reason, any ideas?
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.