Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Throttle increase when turning left
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages:
1
2
Throttle increase when turning left (Read 213 times)
Eegore
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 8330
Re: Throttle increase when turning left
Reply #15 -
05/05/17 at 20:19:08
Resolved the issue by re-routing the cable. It had been pulled under what I assume is some sort of fork-lock key hole. I was able to snap it over the lock and zip-tie it against another cable and it seems to have gone away.
Now if I can just get rid of the belt squeal I might actually ride the thing somewhere.
"Ah , Today I ah
Ah , I ah ""
Whats that about?
Back to top
IP Logged
stewmills
Serious Thumper
Offline
Imagination is more
important than
knowledge
Posts: 2641
Auburn, AL
Gender:
Re: Throttle increase when turning left
Reply #16 -
05/05/17 at 21:29:07
A tight belt can squeal. You should be able to twist the belt 90 degrees with two fingers with light to moderate pressure. If you can't, it is too tight.
Back to top
2008 | 152/52.5–Air Mix 3/4 | Rotella T4 | Seat Lift w/Sheepskin | Speedo Rattle | Rear Pulley Shim | 140/90-15 Rear | Kaw Front Pulley | Relocated Rear Signals
FREEDOM ISN'T FREE!
IP Logged
Ruttly
Serious Thumper
Offline
Thumpers Rule
Posts: 5097
Manteca , CA
Gender:
Re: Throttle increase when turning left
Reply #17 -
05/05/17 at 21:30:57
Comedy my friend Comedy , Welcome to the best motorcycle forum there is.
Check the tech section "belt squeal" I'm sure it's a easy fix. Probably belt alignment. Pulling itself to one side or the other.
Back to top
The Topic Terminator
IP Logged
Gary_in_NJ
Serious Thumper
Offline
LS650 Cafe Racer
Posts: 2633
Amongst the Twisty Roads
Re: Throttle increase when turning left
Reply #18 -
05/06/17 at 09:16:07
Eegore wrote
on 05/05/17 at 20:17:47:
Now if I can just get rid of the belt squeal I might actually ride the thing somewhere.
Belt squeal can be permanently eliminated with a chain conversion
Check the alignment of your rear tire. The rear pulley must be in-line with the front.
Back to top
A life-time student of motorcycling.
LS650 Cafe, DRZ400SM, FZ6N, SV650S, CB900C, Ducati ST2, CB550F-SS
My LS650=>
http://suzukisavage.com/yabb2.2/Attachments/Left.JPG
IP Logged
Eegore
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 8330
Re: Throttle increase when turning left
Reply #19 -
05/06/17 at 09:39:07
Yeah Im not sure its the belt, seems like after 3rd gear its much louder and will make noise even when throttle isn't applied. I had another thread on the issue but at the time it wasn't screaming when coasting with the clutch in.
I need to take a video maybe.
Back to top
IP Logged
justin_o_guy2
Serious Thumper
Offline
What happened?
Posts: 55279
East Texas, 1/2 dallas/la.
Re: Throttle increase when turning left
Reply #20 -
05/06/17 at 11:26:05
So easy to prove.
Gulf canning wax is available at grocery stores, with canning supplies. Rub some on the belt. Squeak stops, f ound it..
Back to top
The people never give up their liberties but under some delusion.- Edmund Burke.
IP Logged
TheNaughtyLemur
Junior Member
Offline
SuzukiSavage.com
Rocks!
Posts: 69
Carlsbad, CA
Gender:
Re: Throttle increase when turning left
Reply #21 -
05/19/17 at 16:32:10
So after removing the carb and rejetting I seem to have the same problem. I've taken the tank off a couple times to see if there was anything amiss, but I haven't noticed anything with the routing. Anything that you guys see?
Back to top
bike_008.jpg
06 Suzuki S40 - 140/90-15 Rear Tyre - Raptor Petcock - MAC 2" Header and Exhaust Kit
IP Logged
Eegore
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 8330
Re: Throttle increase when turning left
Reply #22 -
05/19/17 at 20:22:43
Mine had dropped under the fork lock but it doesn't look like yours did.
It looks like the cable may be able to move a bit up front. Is it draping over the fork lock if you turn right then having tension as you turn left again?
Not sure what else causes this, besides a crimp in the line.
Back to top
IP Logged
TheNaughtyLemur
Junior Member
Offline
SuzukiSavage.com
Rocks!
Posts: 69
Carlsbad, CA
Gender:
Re: Throttle increase when turning left
Reply #23 -
05/19/17 at 20:39:12
It definitely moves when I turn the bike from side to side.
Back to top
06 Suzuki S40 - 140/90-15 Rear Tyre - Raptor Petcock - MAC 2" Header and Exhaust Kit
IP Logged
batman
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 3806
osceola new york
Gender:
Re: Throttle increase when turning left
Reply #24 -
05/19/17 at 21:13:54
the shortest distance between two points is a straight line. I can't tell from the picture is the cable running over the stud for the right side front tank mount? If that's what I'm seeing I'd move it so it runs under the mount.
Back to top
«
Last Edit: 05/21/17 at 18:08:04 by batman
»
my old work mates called me MacGyver
IP Logged
Pages:
1
2
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
09/21/24 at 20:39:41
›
General Category
›
Rubber Side Down!
› Throttle increase when turning left
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.