Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Battery dying when engine hot
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages:
1
...
4
5
6
Battery dying when engine hot (Read 700 times)
norm92de
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 1180
El Paso TX
Gender:
Re: Battery dying when engine hot
Reply #75 -
10/13/15 at 14:27:30
Another thought.
The internal balancer does a pretty good job of controlling the vibration. Even 70 mph is reasonably smooth. incredible for a 650 single!
Back to top
2014 S40. Raptor. idle mixture adj.Needle raised one notch. 4000' altitude. Stock jets. Shell Rotella synthetic.
IP Logged
daincitydave
YaBB Newbies
Offline
SuzukiSavage.com
Rocks!
Posts: 33
Re: Battery dying when engine hot
Reply #76 -
10/13/15 at 19:05:28
part of me is wondering if i was sent the correct regulator; as you have mentioned. i have asked the seller to verify the part was for my bike.
Back to top
IP Logged
daincitydave
YaBB Newbies
Offline
SuzukiSavage.com
Rocks!
Posts: 33
Re: Battery dying when engine hot
Reply #77 -
10/18/15 at 11:29:13
update!
swapped the red wire in the harness and put it in the empty slot.
took bike for two rides. then it would not start. charged it up again. rode to my buddy's house for further testing. after an hour or so he really thought the battery was bad and was not holding a charge. luckily i still had the original battery from the bike before all this began. put that in after getting home. started up fine. took it for a 10 minute ride. started after stopping. did that 3 or 5 more times. started up each time. my buddy really thought all these shorts and problems messed with my battery and it was toast. every few hours i started the bike up yesterday. even today too. it has never started this many times in a row....i want to be cautiously optimistic here as its never been this consistent lol.
Back to top
IP Logged
chzeckmate
Serious Thumper
Offline
Be the person your
dog thinks you are
Posts: 514
Houston, Texas
Gender:
Re: Battery dying when engine hot
Reply #78 -
10/18/15 at 17:59:20
That's entirely possible. I toasted two batteries when my r/r went bad. After I replaced the r/r I had to replace the battery and then all was fine. The thing to do now is test your r/r and the rest of your wiring. A parasitic draw is easy to spot. Just connect the positive lead of your multimeter to any always hot wire and and the negative lead to a good ground...wait...watch. If the voltage gradually drops you have a parasitic draw and you have some diagnosing to do. If the voltage holds you're good.
Back to top
'05 S40, dyna muffler, rejet, high flow filter, Mobil 1 Racing 4T, Shinko 230 set with 140/90 rear, raptor, seat lift, LED running lights/signals, tach, reversed risers, homemade MR10 Lexan windscreen
IP Logged
daincitydave
YaBB Newbies
Offline
SuzukiSavage.com
Rocks!
Posts: 33
Re: Battery dying when engine hot
Reply #79 -
10/18/15 at 18:21:05
while bike is off? on? on and idling?
Back to top
IP Logged
chzeckmate
Serious Thumper
Offline
Be the person your
dog thinks you are
Posts: 514
Houston, Texas
Gender:
Re: Battery dying when engine hot
Reply #80 -
10/18/15 at 19:16:35
Test for parasitic draw while the bike is off. If the voltage holds steady for five minutes you can be pretty sure your r/r is no longer a problem. To be sure you can test the r/r. Here's a YouTube video that shows how
https://www.youtube.com/watch?v=F8EjV0IjW9Q
it's simple. If you get good results then you can attach your positive lead on your multimeter to the positive battery terminal and the negative lead to the negative terminal and start the bike. Rev the motor up to around 3k and you should get around 14.5 volts. If the voltage is lower than 14 you may be looking at a stator problem.
Back to top
'05 S40, dyna muffler, rejet, high flow filter, Mobil 1 Racing 4T, Shinko 230 set with 140/90 rear, raptor, seat lift, LED running lights/signals, tach, reversed risers, homemade MR10 Lexan windscreen
IP Logged
chzeckmate
Serious Thumper
Offline
Be the person your
dog thinks you are
Posts: 514
Houston, Texas
Gender:
Re: Battery dying when engine hot
Reply #81 -
10/21/15 at 00:21:29
I just noticed your post in the "How to test your r/r" in the tech section. After reading that, your post on page 4 of this thread finally made more sense. IIRC, the red wire on your new r/r should go to the empty slot so I think you've done the right thing. If your battery is good and you don't have a parasitic draw anywhere else you should be fine now. I know it's only been a couple of days since you swapped it to the empty slot but I'd like an update on your experience with it when you get the chance.
Back to top
'05 S40, dyna muffler, rejet, high flow filter, Mobil 1 Racing 4T, Shinko 230 set with 140/90 rear, raptor, seat lift, LED running lights/signals, tach, reversed risers, homemade MR10 Lexan windscreen
IP Logged
Pages:
1
...
4
5
6
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
09/28/24 at 06:24:52
›
General Category
›
Rubber Side Down!
› Battery dying when engine hot
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.