SuzukiSavage.com - Smokes a little at startup

Welcome, Guest. Please Login or Register :: View Members

SuzukiSavage.com › General Category › Rubber Side Down! › Smokes a little at startup

(Moderators: verslagen1, Dave, Serowbot)

‹ Previous topic | Next topic ›

Pages: 1

Smokes a little at startup (Read 64 times)

carcaveman

YaBB Newbies

Offline

SuzukiSavage.com
Rocks!

Posts: 35
Tucson, AZ
Gender: male

Smokes a little at startup
11/09/14 at 13:53:18

Is it normal that my bike smokes a bit at startup. The smoke is coming from the exhaust, not just the exhaust hole, but the bellows area (not sure if that's the right term). After about 30 seconds it totally stops and the bike idles fine. It seems that oil is settling somewhere and gets burned off when I start it. It's a stock bike and I checked the oil level and it's above the marks. Got it from the dealer that way. I didn't want to mess with it. If it was too full of oil, would this happen? Could there be a bad seal or loose valve seals?

Thanks, David.

2001 Suzuki Savage

Yamaha Petcock - Done
Chain Tensioner - 8.5 mm (New Chain)
Oil Plug - Done
Handlebars - In progress

PS 24:1
(It's all His.)

IP Logged

Serowbot YaBB Moderator ModSquad Offline OK.... so what's the speed of dark? Posts: 28660 Tucson Az Gender:	Re: Smokes a little at startup Reply #1 - 11/09/14 at 14:30:11 Black smoke = fuel Blue/grey = oil white = water... Water comes from condensation in the pipe... it's very common to all vehicles and harmless... (other than causing rust eventually)...
Back to top	Ludicrous Speed !... ... ... IP Logged

carcaveman YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 35 Tucson, AZ Gender:	Re: Smokes a little at startup Reply #2 - 11/09/14 at 17:58:01 Good point on the color. I should have mentioned it's bluish in color. Also the smell is of oil not just water vapor. Thanks.
Back to top	2001 Suzuki Savage Yamaha Petcock - Done Chain Tensioner - 8.5 mm (New Chain) Oil Plug - Done Handlebars - In progress PS 24:1 (It's all His.) IP Logged

old_rider Serious Thumper Offline Backyard Bill Productions Posts: 3147 flordia panhandle Gender:	Re: Smokes a little at startup Reply #3 - 11/09/14 at 18:02:32 Wouldn't be too hard to loosen the drain plug until it started to run a small stream when you wiggle it or drips quickly. Drain off a small amount until it gets in the proper spot between the lines. Run it a few times and see if it still smokes.
Back to top	We are here to laugh at the odds and live our lives so well that Death will tremble to take us. IP Logged

verslagen1 YaBB Moderator ModSquad Offline Where there's a will, I want to be in it. Posts: 28886 L.A. California Gender:	Re: Smokes a little at startup Reply #4 - 11/09/14 at 20:25:03 The savage isn't real sensitive to overfill. But, if not being able to see the top line sends you into a conniption... remove the timing port cover and it will flow out to about the right level when vertical.
Back to top	Versey's Place Tech Section Index IP Logged

gizzo

Serious Thumper

Offline

SuzukiCabbage. It's
Savage.

Posts: 1318
Australia

Re: Smokes a little at startup
Reply #5 - 11/09/14 at 23:30:28

You could be on the right track : a short period of smoking on startup can be a sign of leaky valve stem seals or worn valve guides. When the engine sits ,oil can drain down the valve stem into the combustion chamber. No biggie but will eventually carbon up the back of the valve head.
Not sure what you meant by the "bellows area" tho.
Had a bmw k75 that smoked like a train if it was left on the side stand overnight. Stand should have been on the sump side of the engine...

IP Logged

carcaveman YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 35 Tucson, AZ Gender:	Re: Smokes a little at startup Reply #6 - 11/10/14 at 08:27:16 Yeah bellows wasn't the right word. Most of the smoke is coming out of the area where of the exhaust system where the single tube goes into the larger end piece of the exhaust. I guess that's the muffler.
Back to top	2001 Suzuki Savage Yamaha Petcock - Done Chain Tensioner - 8.5 mm (New Chain) Oil Plug - Done Handlebars - In progress PS 24:1 (It's all His.) IP Logged

Pages: 1

‹ Previous topic | Next topic ›

« Home