shovelbum87
Full Member
Offline
SuzukiSavage.com Rocks!
Posts: 158
New Hampshire
Gender:
|
Hi all, Im having trouble, again...
here is what I am looking at;
Last summer took the bike for a ride stopped for coffee shut it off and sat had a coffee chilled out, hopped on and went to start it and there is nothing, no crank no nothing, we attempt to push start her and after having the rear wheel locked up on us and we looked foolish for a half of an hour this very kind man comes over and offers to lend us a set of jumper cables so we try it and she fires up and dies out if the throttle isn't at about half... long story short we get it home and call it a day. So we charge the battery (I assume that I left the switch on park) put it back in and she cranks a couple times then nothing, put a jump pack on it it fires and runs. shut it down try again, cranks acouple times and then the starter solenoid clicks. I start chasing the wires off the regulator/rectifier and find that the wires out of the stator are shot, insulation is gone and they are shorting out, so I pull the cover off solder on new wires and splice them in to the harness. try to start it fires right up! but after about 5 min of running the pipe is bright red due to too much fuel from a carb that has a slight needle problem, I purchase a carb from Uriah, put it on it runs great!!! but same deal if you put a jump pack on it it will start but the battery isn't holding a charge I think, grab a battery put it in and now all she does is crank and crank and crank, will not fire. Has spark, has fuel and I am at a loss of what the heck ails her.
Any input would be greatly appreciated!
1987 savage raptor pet, no other mods
|