SuzukiSavage.com - No neutral light

Welcome, Guest. Please Login or Register :: View Members

SuzukiSavage.com › General Category › Rubber Side Down! › No neutral light

(Moderators: verslagen1, Dave, Serowbot)

‹ Previous topic | Next topic ›

Pages: 1

No neutral light (Read 54 times)

bmwnunkie YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 28	No neutral light 05/11/14 at 03:47:50 I get no neutral light when I start up. It is in neutral as the bike starts. If I engage a gear ( 1st, 2nd ) the engine dies completely. Also it backfires like its going out of fashion. Where do it start... getting a bit fed up
Back to top	IP Logged

Dave

YaBB Moderator
ModSquad

Offline

SuzukiSavage.com
Rocks!

Posts: 18099
Camp Springs, Kentucky
Gender: male

Re: No neutral light
Reply #1 - 05/11/14 at 04:50:24

There is a sensor switch in the bottom right side of the engine. The wire comes out of the engine at the bottom back right side of the engine case, travels up the right frame tube, and then goes up under the tank to a connector on the right side of the center frame tube under the gas tank. The wire is bright blue. You need to make sure the wire is connected and not broken somewhere. Disconnect the wire at the connector and test to see it the switch provides a ground when the bike is in neutral....and an open circuit when the bike is in gear.

Someday I will be old......But not today!

IP Logged

WD Serious Thumper 2005 No Login Offline Professional "scooter trash". Posts: 5207 Rosemark TN Gender:	Re: No neutral light Reply #2 - 05/11/14 at 08:32:06 Kickstand switch is also wired into that circuit... It is a guaranteed to fail item, and it will do exactly as described when it fails. Green connector set under the left hand side cover. Unhook the sections, jumper wire in the bike side connector, see if it behaves.
Back to top	On 2 wheels since 7/87 Black and Chrome 2003 1950s style custom IP Logged

runwyrlph Serious Thumper Offline Semper ubi sub ubi Posts: 846 pa Gender:	Re: No neutral light Reply #3 - 05/11/14 at 12:31:36 yah, maybe the neutral light bulb just burned out? Dying when put in gear sounds like kickstand switch. You do have the kickstand up,right? -and the "backfire" never goes out of fashion!
Back to top	2007 s40 -stock -white spacer out -repaired to rideable condition! IP Logged

Dane Allen Serious Thumper Offline Carpe Diem!! Posts: 1217 Riverside, CA Gender:	Re: No neutral light Reply #4 - 05/12/14 at 11:05:04 The afterfire on shutdown is cured by putting the gear into 2nd and stalling out the bike.
Back to top	RIP!! 01/2012-09/2016 S40 Boulevard, Raptor Pet, Rotella T6 Synth, Verslavy CC Tensioner -- You left too soon. IP Logged

Pages: 1

‹ Previous topic | Next topic ›

« Home