Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› No neutral light
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages: 1
No neutral light (Read 54 times)
bmwnunkie
YaBB Newbies
Offline
SuzukiSavage.com
Rocks!
Posts: 28
No neutral light
05/11/14 at 03:47:50
I get no neutral light when I start up. It is in neutral as the bike starts. If I engage a gear ( 1st, 2nd ) the engine dies completely. Also it backfires like its going out of fashion.
Where do it start... getting a bit fed up
Back to top
IP Logged
Dave
YaBB Moderator
ModSquad
Offline
SuzukiSavage.com
Rocks!
Posts: 18099
Camp Springs, Kentucky
Gender:
Re: No neutral light
Reply #1 -
05/11/14 at 04:50:24
There is a sensor switch in the bottom right side of the engine. The wire comes out of the engine at the bottom back right side of the engine case, travels up the right frame tube, and then goes up under the tank to a connector on the right side of the center frame tube under the gas tank. The wire is bright blue. You need to make sure the wire is connected and not broken somewhere. Disconnect the wire at the connector and test to see it the switch provides a ground when the bike is in neutral....and an open circuit when the bike is in gear.
Back to top
Someday I will be old......But not today!
IP Logged
WD
Serious Thumper
2005 No Login
Offline
Professional
"scooter
trash".
Posts: 5207
Rosemark TN
Gender:
Re: No neutral light
Reply #2 -
05/11/14 at 08:32:06
Kickstand switch is also wired into that circuit... It is a guaranteed to fail item, and it will do exactly as described when it fails. Green connector set under the left hand side cover. Unhook the sections, jumper wire in the bike side connector, see if it behaves.
Back to top
On 2 wheels since 7/87
Black and Chrome 2003 1950s style custom
IP Logged
runwyrlph
Serious Thumper
Offline
Semper ubi sub ubi
Posts: 846
pa
Gender:
Re: No neutral light
Reply #3 -
05/11/14 at 12:31:36
yah, maybe the neutral light bulb just burned out? Dying when put in gear sounds like kickstand switch.
You do have the kickstand up,right?
-and the "backfire" never goes out of fashion!
Back to top
2007 s40 -stock -white spacer out -repaired to rideable condition!
IP Logged
Dane Allen
Serious Thumper
Offline
Carpe Diem!!
Posts: 1217
Riverside, CA
Gender:
Re: No neutral light
Reply #4 -
05/12/14 at 11:05:04
The afterfire on shutdown is cured by putting the gear into 2nd and stalling out the bike.
Back to top
RIP!! 01/2012-09/2016 S40 Boulevard, Raptor Pet, Rotella T6 Synth, Verslavy CC Tensioner -- You left too soon.
IP Logged
Pages: 1
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
09/29/24 at 06:23:27
›
General Category
›
Rubber Side Down!
› No neutral light
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.