Donate!
Welcome, Guest. Please Login or Register :: View Members
SuzukiSavage.com › General Category › Rubber Side Down! › Gas cap cleaning.. which method?
(Moderators: verslagen1, Dave, Serowbot) ‹ Previous topic | Next topic ›
Pages: 1 2 
Send Topic Print
Gas cap cleaning.. which method? (Read 126 times)
Built2Last
Serious Thumper
*****
Offline

Tempt Fate

Posts: 1447
FTF
Gender: male
Gas cap cleaning.. which method?
10/11/11 at 09:44:51  
So I finally have my gas cap leak proof, now at 60+ MPH I get the "out of gas" engine cut off... I know my vacuum and petcock are good since I only got this problem once my gas cap seal was sealed air tight, so apparently the breather in my gas cap is clogged/dirty. I've been suggested cleaning it with carb cleaner, but I was also thinking of soaking it in lighter fluid (this is just a wild shot in the dark).. but I don't know exactly where the breather hole is.. so any recommendations on how to clean it would help, other wise I'm going to switch to a Raptor petcock but I need to take a few trips before it would even arrive.

Thanks
Back to top
 
 
  IP Logged
Serowbot
YaBB Moderator
ModSquad
*****
Offline

OK.... so what's the
speed of dark?

Posts: 28635
Tucson Az
Gender: male
Re: Gas cap cleaning.. which method?
Reply #1 - 10/11/11 at 10:14:57  
A Raptor won't help a clogged gas cap vent...  You need to fix that...

Get a spray carb cleaner, and squirt a heavy dose in every tiny opening you can find... then shake the crap out of it,... then blow it out with compressed air... (if you don't have a compressor, you can buy canned air)... shake it madly again... (PS,.. I'd like video of this, if you can... Grin)...
That'll probably work better than a soak,.. because of the spray pressure...

If it's like other caps I've seen,.. there's a BB in there that covers a tiny air hole,.. and yours is stuck...

Rotsa' ruck... Wink...
Back to top
 
 
Ludicrous Speed !... ... Huh...
  IP Logged
Built2Last
Serious Thumper
*****
Offline

Tempt Fate

Posts: 1447
FTF
Gender: male
Re: Gas cap cleaning.. which method?
Reply #2 - 10/11/11 at 10:24:39  
Serowbot wrote on 10/11/11 at 10:14:57:
A Raptor won't help a clogged gas cap vent...  You need to fix that...

Get a spray carb cleaner, and squirt a heavy dose in every tiny opening you can find... then shake the crap out of it,... then blow it out with compressed air... (if you don't have a compressor, you can buy canned air)... shake it madly again... (PS,.. I'd like video of this, if you can... Grin)...
That'll probably work better than a soak,.. because of the spray pressure...

If it's like other caps I've seen,.. there's a BB in there that covers a tiny air hole,.. and yours is stuck...

Rotsa' ruck... Wink...


Nope I can hear that bb rollin around in there.. I thought I put it back together wrong cause of that thing... oh wells, I'll give it a carb cleaning, which kind should I get from a local store? I have an air compressor so I don't need a can of Dust Off.. well I do.. but I won't waste it on the gas cap...  Wink
Back to top
 
 
  IP Logged
Serowbot
YaBB Moderator
ModSquad
*****
Offline

OK.... so what's the
speed of dark?

Posts: 28635
Tucson Az
Gender: male
Re: Gas cap cleaning.. which method?
Reply #3 - 10/11/11 at 10:28:53  
... after thinking about it,... Your problem with gas cap leaking probably caused this...  but, simply sealing the cap rim won't fix it...
The reason caps leak, is that the tank is overfilled...
Sealing the rim, allows you to overfill without leaking, but the gas is still up there,.. that gas, is working it's way into the cap leaving a residue that lacquers up and clogs the vent...
Best to try to fill a little less,... and this problem won't recur... Wink...

I'd use whatever cheapest,...  "cause I'm cheap... Grin...
Back to top
 
 
Ludicrous Speed !... ... Huh...
  IP Logged
Built2Last
Serious Thumper
*****
Offline

Tempt Fate

Posts: 1447
FTF
Gender: male
Re: Gas cap cleaning.. which method?
Reply #4 - 10/11/11 at 10:33:49  
Serowbot wrote on 10/11/11 at 10:28:53:
The reason caps leak, is that the tank is overfilled...


It was spewing out like Niagra Falls even when under an inch from the fill line in the manual.. I fill it up exactly how the manual says to, I don't over fill it, because then I can't measure the exact amount of needed Sea Foam, and I only use Pee Foam when I'm out of gas... maybe when I poo through the key hole it's getting clogged?
Back to top
 
 
  IP Logged
Built2Last
Serious Thumper
*****
Offline

Tempt Fate

Posts: 1447
FTF
Gender: male
Re: Gas cap cleaning.. which method?
Reply #5 - 10/11/11 at 10:35:17  
What kind of carb cleaner can I get from say Advance Auto that will be reusable if I do actually ever clean my carb? (I've never ever bought carb cleaner or cleaned a carb so I'm like "dur")
Back to top
 
 
  IP Logged
Serowbot
YaBB Moderator
ModSquad
*****
Offline

OK.... so what's the
speed of dark?

Posts: 28635
Tucson Az
Gender: male
Re: Gas cap cleaning.. which method?
Reply #6 - 10/11/11 at 10:36:58  
Built2Last wrote on 10/11/11 at 10:33:49:
... maybe when I poo through the key hole it's getting clogged?


Jeepers!... That'll do it, alright... Huh...
Back to top
 
 
Ludicrous Speed !... ... Huh...
  IP Logged
Built2Last
Serious Thumper
*****
Offline

Tempt Fate

Posts: 1447
FTF
Gender: male
Re: Gas cap cleaning.. which method?
Reply #7 - 10/11/11 at 10:37:58  
Another thing I just thought of.. maybe I'm tightening the screws in too tight on the bottom of the cap.. and bending something not allowing the tiny hole to breathe?
Back to top
 
 
  IP Logged
SurfJunkie
Junior Member
**
Offline

SuzukiSavage.com
Rocks!

Posts: 66
Re: Gas cap cleaning.. which method?
Reply #8 - 10/11/11 at 10:39:03  
Just buy the big red can with a white label that says CARB CLEANER or CLEAN R CARB lol. If you use it alot ( takes oil stains off the garage floor if you get to it within 5-10 mins. ) get the big ass can.

Its all the same. If it says CARB CLEANER, tis good enough.
Back to top
 
 
  IP Logged
Serowbot
YaBB Moderator
ModSquad
*****
Offline

OK.... so what's the
speed of dark?

Posts: 28635
Tucson Az
Gender: male
Re: Gas cap cleaning.. which method?
Reply #9 - 10/11/11 at 10:40:05  
Built2Last wrote on 10/11/11 at 10:37:58:
Another thing I just thought of.. maybe I'm tightening the screws in too tight on the bottom of the cap.. and bending something not allowing the tiny hole to breathe?

Nope,... if you don't tighten them down good,... you'll be fishin'...
It's a clogged passage... Spray away... if that don't work,.. take it apart again...
Back to top
 
 
Ludicrous Speed !... ... Huh...
  IP Logged
Built2Last
Serious Thumper
*****
Offline

Tempt Fate

Posts: 1447
FTF
Gender: male
Re: Gas cap cleaning.. which method?
Reply #10 - 10/11/11 at 10:42:07  
Quote:
Spray away... if that don't work,.. take it apart again...


What kind of spray is good please sir... from a local place (Advance Auto, Autozone, Wal-Mart, 711)?
Back to top
 
 
  IP Logged
SurfJunkie
Junior Member
**
Offline

SuzukiSavage.com
Rocks!

Posts: 66
Re: Gas cap cleaning.. which method?
Reply #11 - 10/11/11 at 12:02:20  
built.

http://www.oreillyauto.com/site/c/detail/CRC7/05081.oap?ck=Search_carb+cleane...

Any aerosol can of stuff labeled "carb cleaner" should do.

I prefer the above.
Back to top
 
 
  IP Logged
justin_o_guy2
Serious Thumper
*****
Offline

What happened?

Posts: 55279
East Texas, 1/2 dallas/la.
Re: Gas cap cleaning.. which method?
Reply #12 - 10/11/11 at 17:36:06  
A bit o diesel in a small can & dunk it, then blow it out,, Wear eyeball pertekshun,,
Back to top
 
 
The people never give up their liberties but under some delusion.- Edmund Burke.
  IP Logged
Built2Last
Serious Thumper
*****
Offline

Tempt Fate

Posts: 1447
FTF
Gender: male
Re: Gas cap cleaning.. which method?
Reply #13 - 10/11/11 at 17:44:55  
I cleaned it with an air compressor and some STP carb cleaner I found layin around.. so far when I take off the gas cap there's no more suction sound, but it's been raining so I haven't fired it up today at all..
Back to top
 
 
  IP Logged
thumperclone
Serious Thumper
Alliance Member
*****
Offline

PGR rider  riding
with respect

Posts: 6045
Grand Junction Colorado
Gender: male
Re: Gas cap cleaning.. which method?
Reply #14 - 10/11/11 at 17:52:12  
Built2Last wrote on 10/11/11 at 17:44:55:
I cleaned it with an air compressor and some STP carb cleaner I found layin around.. so far when I take off the gas cap there's no more suction sound, but it's been raining so I haven't fired it up today at all..

no run no suck


squeeze bang blow
Back to top
 
 
standing for those who stood for US
















  IP Logged
Pages: 1 2 
Send Topic Print
‹ Previous topic | Next topic ›


« Home

 
« Home
SuzukiSavage.com
09/21/24 at 07:03:27



› General Category › Rubber Side Down! › Gas cap cleaning.. which method?


SuzukiSavage.com » Powered by YaBB 2.2!
YaBB © 2000-2007. All Rights Reserved.