Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Bike starts up, dies when I give it throttle
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages: 1
Bike starts up, dies when I give it throttle (Read 92 times)
yumi
Junior Member
Offline
2004 Purple
Posts: 57
gainesville, fl
Gender:
Bike starts up, dies when I give it throttle
01/29/11 at 08:33:19
Bike starts up if I let OFF the throttle completely.. (I'm about 1/4 throttle when I hit the starter, then gradually let off until it turns on --- it wasn't always like this, but I think it started after we upped the jets)
It will sit there and idle all day long but if I give just a bit of throttle it dies immediately.
If I'm REALLY feeding it, it stutters and smokes from the cylinder head for a moment, then dies.
I let my boyfriend mess with it too much and now I don't know how to clean up after him. Any suggestions would be greatly appreciated.
Thanks,
Michelle
Back to top
IP Logged
verslagen1
YaBB Moderator
ModSquad
Offline
Where there's a
will, I want to be
in it.
Posts: 28884
L.A. California
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #1 -
01/29/11 at 08:36:33
What jets did he put in?
Sounds like the jets are too big.
Most of us start with no throttle, and I think starting with is an indication of too lean.
Back to top
Versey's Place
Tech Section Index
IP Logged
Trippah
Serious Thumper
Offline
I ride, therefore I
am.
Posts: 2517
central Mass
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #2 -
01/29/11 at 08:43:05
Michelle, are we discussing replacing the jets or the boyfriend????
Back to top
IP Logged
yumi
Junior Member
Offline
2004 Purple
Posts: 57
gainesville, fl
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #3 -
01/29/11 at 08:46:53
I knew that was coming. Main is 152.5. Pilot I can't remember but I will go digging. Actually I am pretty sure its a 55. He replaced the airbox with a cone filter, too.
Any ideas on why it will start up and idle just fine but dies if I give it throttle?
Trippah, that depends on how much nuts I have to go through to fix it.
Back to top
IP Logged
yumi
Junior Member
Offline
2004 Purple
Posts: 57
gainesville, fl
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #4 -
01/29/11 at 08:47:51
It's an '04.
http://suzukisavage.com/cgi-bin/YaBB.pl?board=tech;action=display;num=1098869040
I think I'm 2-3 sizes up on each jet.
Back to top
IP Logged
verslagen1
YaBB Moderator
ModSquad
Offline
Where there's a
will, I want to be
in it.
Posts: 28884
L.A. California
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #5 -
01/29/11 at 09:10:03
yumi wrote
on 01/29/11 at 08:46:53:
I knew that was coming. Main is 152.5. Pilot I can't remember but I will go digging. Actually I am pretty sure its a 55. He replaced the airbox with a cone filter, too.
Any ideas on why it will start up and idle just fine but dies if I give it throttle?
Trippah, that depends on how much nuts I have to go through to fix it.
152 should be ok, but you're at sea level and have a cone filter, might have to go larger.
Starts fine and idles cause the pilot jet is right, leave that one alone.
Can't advise you on your sex life.
Back to top
Versey's Place
Tech Section Index
IP Logged
Trippah
Serious Thumper
Offline
I ride, therefore I
am.
Posts: 2517
central Mass
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #6 -
01/29/11 at 09:15:16
Before I go outside to shovel some snow, I'd make these two quick comments. You should not have to open the throttle at all when starting the bike;pulling the "choke", actually an enrichening circuit I think should do the job when its cold. and if it is idling OK, when you twist the throttle, the needle slide is moved (raised) (hopefully) so perhaps yours isn't seated fully and floods the carb when you twist the throttle.
Best of luck, now I'll leave it to the experts to chime in.....
Back to top
IP Logged
Serowbot
YaBB Moderator
ModSquad
Offline
OK.... so what's the
speed of dark?
Posts: 28638
Tucson Az
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #7 -
01/29/11 at 10:26:44
There's a brass washer that's supposed to go under the main jet...
I'll bet he left it off...
...
Back to top
Ludicrous Speed !... ...
...
IP Logged
yumi
Junior Member
Offline
2004 Purple
Posts: 57
gainesville, fl
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #8 -
01/29/11 at 16:47:50
Serowbot wrote
on 01/29/11 at 10:26:44:
There's a brass washer that's supposed to go under the main jet...
I'll bet he left it off...
...
Hmm he upped the jets in September; I didn't have this problem until just a week or two ago.
Back to top
IP Logged
yumi
Junior Member
Offline
2004 Purple
Posts: 57
gainesville, fl
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #9 -
01/29/11 at 16:49:19
verslagen1 wrote
on 01/29/11 at 09:10:03:
152 should be ok, but you're at sea level and have a cone filter, might have to go larger.
Starts fine and idles cause the pilot jet is right, leave that one alone.
Can't advise you on your sex life.
How much larger on the main would you suggest?
Back to top
IP Logged
verslagen1
YaBB Moderator
ModSquad
Offline
Where there's a
will, I want to be
in it.
Posts: 28884
L.A. California
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #10 -
01/29/11 at 18:33:56
yumi wrote
on 01/29/11 at 16:47:50:
Serowbot wrote
on 01/29/11 at 10:26:44:
There's a brass washer that's supposed to go under the main jet...
I'll bet he left it off...
...
Hmm he upped the jets in September; I didn't have this problem until just a week or two ago.
what happened a week or 2 ago?
Back to top
Versey's Place
Tech Section Index
IP Logged
james may
Senior Member
Offline
SuzukiSavage.com
Rocks!
Posts: 252
holyoke, ma
Gender:
Re: Bike starts up, dies when I give it throttle
Reply #11 -
01/29/11 at 18:53:28
checked to make sure your getting enough fuel? tank could be low or could have the vacuum problem.. although it would probably eventually not start and idle at all if it was fuel blockage. Does sound like a carb issue.. ya could take it apart and give it a good clearning make sure none of the rubber parts are not damaged in any way. Check the plug to see if your running too lean or too rich.. How do the various choke positions effect the startup idle and running? if it works better at half or full choke then might be running lean.. did you modify the spacer? skrewing with the needle settings often can cause unpredictible behavior.
Back to top
Weightloss Blog
http://atomsweightlosschronicles.blogspot.com
IP Logged
Pages: 1
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
09/22/24 at 09:25:00
›
General Category
›
Rubber Side Down!
› Bike starts up, dies when I give it throttle
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.