SuzukiSavage.com - WTF?!?!?! NOT RESOLVED.....

logan31907

Junior Member

Offline

SuzukiSavage.com
Rocks!

Posts: 54

Re: WTF?!?!?! NOT RESOLVED.....
Reply #30 - 01/22/11 at 16:30:05

Bubba wrote on 01/22/11 at 16:21:12:

Logan, do yourself a favor and read the links that were posted...they explain everything.
For me the raptor was an easy switch, cheaper than the stock one and in the past I had ridden bikes that you had to turn the fuel off when done riding so it wasn't that hard to remember.

Sorry for all the questions. I will read the links....its just that I'm at work right now posting with my blackberry.

Back to top

IP Logged

Bubba Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 956 Denver, CO Gender:	Re: WTF?!?!?! NOT RESOLVED..... Reply #31 - 01/22/11 at 17:10:41 No apologies necessary, we all have to start somewhere. The folks here have saved me lots of heartache... A great forum...the BEST!!!
Back to top	'06 lt Blue, Dyna Power pipe, air screw 2 1/4 turns, 52.5 pilot w/ bleed holes, 150 Main, 2/3 spacer, Pirelli MT66 tires, Raptor petcock, 412-4006 Progressive shocks IP Logged

Boule’tard

Serious Thumper
ModSquad

Offline

Master of the
Obvious

Posts: 1620
Austin TX
Gender: male

Re: WTF?!?!?! NOT RESOLVED.....
Reply #32 - 01/22/11 at 17:25:22

logan31907 wrote on 01/22/11 at 16:06:54:

Will I still have the ability to "prime" with the raptor petcock since "on" means "prime" ? Also, did I damage anything when I rode about 5 miles with the choke open? How do I turn it off?....is there a different switch on the raptor petcock? And why is it necessary to turn it off? And do I turn it off after each ride? Or just at the end of the day?

Yes, like Serowbot says, the Raptor's "on" is the same as the stock petcock's "prime." That is, really ON Cheesy

With the Raptor, off=off
You did not damage anything by running rich for 5 miles.

Opinions differ on how often it is necessary to turn a manual petcock on and off. If the float valve in your carb is 100% trustworthy, you never need to turn it off. Most seep a little over time, therefore the shutoff valve exists. Turning it off for a 10-minute stop is a little obsessive IMO. I say turn it off overnight or any time the bike will sit for more than a couple hours. Don't worry about it too much between rides, running errands and whatnot.

Back to top

That which can be destroyed by the truth should be. - P.C. Hodgell

IP Logged

logan31907

Junior Member

Offline

SuzukiSavage.com
Rocks!

Posts: 54

Re: WTF?!?!?! NOT RESOLVED.....
Reply #33 - 01/22/11 at 17:39:15

So I just got home from work, about a 10 minute ride, and I'd figure I would switch it to the "on" position to see what would happen. And it didn't die or stall on me this time. Is the petcock still the culprit if its an intermittent problem?

also, with the raptor petcock, I understand that on = on, and that on = prime also. Does that mean there is no separate position/switch for prime? So on = on = prime? Would I still be using the stock fuel switch (I.e. For reserve, prime, and on). And if I still do use the stock switch, will the "prime" position still work like its suPposed to (since on=on=prime)? Its difficult for me to comprehend...I know, I'm an idiot.

Back to top

IP Logged

Boule’tard

Serious Thumper
ModSquad

Offline

Master of the
Obvious

Posts: 1620
Austin TX
Gender: male

Re: WTF?!?!?! NOT RESOLVED.....
Reply #34 - 01/22/11 at 17:52:28

Yes, the intermittent problem that does not show itself over a 10-mile ride is very likely still a problem with the auto-petcock sytem, such as a small hole in the vacuum diaphragm, a tiny crack in the vacuum line, or a poor-sealing hose connection.

To help understand how it works.. think of the vacuum system as an invisible hand that turns the petcock from "ON" to "PRIME" as soon as you start the engine, and leaves it there until you shut it down.

Converting that to Raptor/manual petcock language, it's turning the petcock from "OFF" to "ON" while the engine is running.

The word "ON" on the stock petcock is a misnomer, but I guess "OFF UNLESS THE ENGINE IS ON" wouldn't fit on there. Grin

Back to top

That which can be destroyed by the truth should be. - P.C. Hodgell

IP Logged

logan31907 Junior Member Offline SuzukiSavage.com Rocks! Posts: 54	Re: WTF?!?!?! NOT RESOLVED..... Reply #35 - 01/22/11 at 18:05:50 Ok...so, with the raptor petcock, there's 2 positions...on and reserve? And if I ever needed to use "prime" its just the "on" position?
Back to top	IP Logged

Boule’tard Serious Thumper ModSquad Offline Master of the Obvious Posts: 1620 Austin TX Gender:	Re: WTF?!?!?! NOT RESOLVED..... Reply #36 - 01/22/11 at 18:22:28 There's on, off and reserve. Reserve just lets it draw the gas down to a lower level, pretty much all the gas in the tank. Correct that the Raptor's "ON" is the old "PRIME." You got it
Back to top	That which can be destroyed by the truth should be. - P.C. Hodgell IP Logged

logan31907 Junior Member Offline SuzukiSavage.com Rocks! Posts: 54	Re: WTF?!?!?! NOT RESOLVED..... Reply #37 - 01/23/11 at 11:33:49 So I did the test from the links provided. I took the vacuum off and sucked on it and gas came out. I then plugged the lines, ran it on prime, and it ran good. Petcock diaphragm
Back to top	IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: WTF?!?!?! NOT RESOLVED..... Reply #38 - 01/23/11 at 11:36:44 & the trumpets blared Dunt duh duh Duuuuuh! Congrats!
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

logan31907 Junior Member Offline SuzukiSavage.com Rocks! Posts: 54	Re: WTF?!?!?! NOT RESOLVED..... Reply #39 - 01/23/11 at 13:29:32 So I'll order a raptor petcock on ebay (unless someone knows a better vendor) ans will let ya'll know how it goes. THANK YOU EVERYONE!!!!! Suzukisavage.com kicks a$$!!!!
Back to top	IP Logged

logan31907

Junior Member

Offline

SuzukiSavage.com
Rocks!

Posts: 54

Re: could it be the stator? - i dont think so?....
Reply #40 - 01/23/11 at 14:26:45

Bubba wrote on 01/20/11 at 06:37:43:

Logan, either rebuild the petcock, buy a new one for WAY too much money or swap it out with a raptor (straight swap).

http://www.ronayers.com/Search/N/687/Criteria/5LP-24500-01-00&adv=5&kw...

If you go the raptor route you will need to shut off the fuel every time you turn off the bike...old school, and block off the vac line on the carb.
I went the raptor route...no problems so far...

What year raptor do I use?

Is that link for a oem petcock or raptor? And is it new or used?
I went to that site, but it only gave a product number as the description

Back to top

IP Logged

Serowbot YaBB Moderator ModSquad Offline OK.... so what's the speed of dark? Posts: 28633 Tucson Az Gender:	Re: WTF?!?!?! NOT RESOLVED..... Reply #41 - 01/23/11 at 14:54:07 That's a Raptor.... ...
Back to top	Ludicrous Speed !... ... ... IP Logged

logan31907 Junior Member Offline SuzukiSavage.com Rocks! Posts: 54	Re: WTF?!?!?! NOT RESOLVED..... Reply #42 - 01/23/11 at 16:44:59 Serowbot wrote on 01/23/11 at 14:54:07: That's a Raptor.... ... What year is it for?
Back to top	IP Logged

Serowbot YaBB Moderator ModSquad Offline OK.... so what's the speed of dark? Posts: 28633 Tucson Az Gender:	Re: WTF?!?!?! NOT RESOLVED..... Reply #43 - 01/23/11 at 17:41:30 logan31907 wrote on 01/23/11 at 16:44:59: Serowbot wrote on 01/23/11 at 14:54:07: That's a Raptor.... ... What year is it for? all of 'em...
Back to top	Ludicrous Speed !... ... ... IP Logged

logan31907 Junior Member Offline SuzukiSavage.com Rocks! Posts: 54	Re: WTF?!?!?! NOT RESOLVED..... Reply #44 - 01/23/11 at 19:26:43 Serowbot wrote on 01/23/11 at 17:41:30: logan31907 wrote on 01/23/11 at 16:44:59: Serowbot wrote on 01/23/11 at 14:54:07: That's a Raptor.... ... What year is it for? all of 'em... Ok. So any year raptor can replace any year savage?
Back to top	IP Logged