Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Super high idle and no throttle response
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages: 1
Super high idle and no throttle response (Read 117 times)
Scott_H
Full Member
Offline
SuzukiSavage.com
Rocks!
Posts: 130
Escondido, CA
Gender:
Super high idle and no throttle response
04/26/10 at 12:28:01
I took off the carb, changed jets and added a cone type filter and removed the muffler (waiting on new one to come in). I put everything back together and started it up and the just just runs at a super high speed. Twisting the throttle has no effect. Any ideas on what I did wrong? Could this be caused by a vacuum leak?
At the same time, I also replaced the petcock on the tank with a Raptor one and removed the charcoal canister (it's a CA bike)
Thanks,
Scott
Back to top
«
Last Edit: 04/26/10 at 13:29:51 by Scott_H
»
IP Logged
verslagen1
YaBB Moderator
ModSquad
Online
Where there's a
will, I want to be
in it.
Posts: 28886
L.A. California
Gender:
Re: Super high idle and no throttle response
Reply #1 -
04/26/10 at 12:57:49
I think you put it back together with the cable stuck somewhere.
Back to top
Versey's Place
Tech Section Index
IP Logged
Scott_H
Full Member
Offline
SuzukiSavage.com
Rocks!
Posts: 130
Escondido, CA
Gender:
Re: Super high idle and no throttle response
Reply #2 -
04/26/10 at 13:27:33
The cable is attached to the carb and when I twist the throttle, it actuates the carb.
Back to top
IP Logged
verslagen1
YaBB Moderator
ModSquad
Online
Where there's a
will, I want to be
in it.
Posts: 28886
L.A. California
Gender:
Re: Super high idle and no throttle response
Reply #3 -
04/26/10 at 14:08:00
Did you push the carb fully into the intake manifold (rubber bushing)?
And did you plug the cannister port?
Back to top
Versey's Place
Tech Section Index
IP Logged
Scott_H
Full Member
Offline
SuzukiSavage.com
Rocks!
Posts: 130
Escondido, CA
Gender:
Re: Super high idle and no throttle response
Reply #4 -
04/26/10 at 15:30:19
You were right the first time. The throttle cable is not kinked and I had it connected but it was "pulling" the carb open due to it being about 1/4 inch too short.
I do have the the cable in the little "socket" with the snap ring attached to the carb and the "t" at the end of the cable in the appropriate slot. But when I do this it "pulls" the carb open a bit. I'm not sure how that could have happened.
I'll have to take the tank back off to see what is going on under there.
Thanks for the quick response!
Back to top
IP Logged
LANCER
Serious Thumper
Alliance Member
Online
Savage Beast
Performance Parts
Posts: 10663
Oklahoma
Gender:
Re: Super high idle and no throttle response
Reply #5 -
04/27/10 at 01:49:41
yes, something is not fitted properly with the cable.
as you said, remove the tank and remove & replace the cable again...check good cable action before putting the tank back on.
then check it again after the tank is on.
Back to top
IP Logged
Scott_H
Full Member
Offline
SuzukiSavage.com
Rocks!
Posts: 130
Escondido, CA
Gender:
Re: Super high idle and no throttle response
Reply #6 -
04/27/10 at 08:08:26
Ended up being the throttle return wasn't working. When I disconnected the cable from the carb and turned the throttle, the cable just wound up in the throttle at the bar and got "sucked" up into the sheath. Disassembled the throttle, oiled, and reset the cable. Now works great!
Back to top
IP Logged
Pages: 1
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
09/26/24 at 18:28:09
›
General Category
›
Rubber Side Down!
› Super high idle and no throttle response
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.