Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› white spacer mod, now bike runs like a moped
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages:
1
2
white spacer mod, now bike runs like a moped (Read 400 times)
Serowbot
YaBB Moderator
ModSquad
Offline
OK.... so what's the
speed of dark?
Posts: 28657
Tucson Az
Gender:
Re: white spacer mod, now bike runs like a moped
Reply #15 -
06/03/09 at 17:39:26
One number #4 nylon washer from Ace Hardware measures out at exactly 2/3's the thickness of the stock washer...
Sounds to me like your needle has stuck.
Back to top
Ludicrous Speed !... ...
...
IP Logged
Serowbot
YaBB Moderator
ModSquad
Offline
OK.... so what's the
speed of dark?
Posts: 28657
Tucson Az
Gender:
Re: white spacer mod, now bike runs like a moped
Reply #16 -
06/03/09 at 17:45:02
diamond jim wrote
on 06/03/09 at 16:18:04:
The notches- that's what I mean. Can the plate be installed wrong and if so what could effects be? Are they for vacuum?
I did notice a tiny, tiny dimple on one side of the plate, but it doesn't seem to line up to anything, and seems too small to have any real effect on function.
Puzzling?... I doubt it makes any difference to anything...
Back to top
Ludicrous Speed !... ...
...
IP Logged
BurnPgh
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 1732
Re: white spacer mod, now bike runs like a moped
Reply #17 -
06/04/09 at 00:25:45
There are two dimples in the plate on one side. the plate needs to be the right way up. I don't recall which is the right way offhand however. If the plate is upside down it wont align correctly with those holes in the bottom of the slide. I don't know what they are for but right side up the holes are both completely open. They're above half covered if you flip it over and bolt it down. That may be your issue.
Back to top
IP Logged
dasch
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 1137
Re: white spacer mod, now bike runs like a moped
Reply #18 -
06/04/09 at 04:23:21
Absolutely right. Right side up - holes open. Wrong side up - half closed. Just doesn't look right. I can't remember either where the dimple go
Back to top
IP Logged
PipJones
Full Member
Offline
Posts: 146
Fort Worth, Tx
Gender:
Re: white spacer mod, now bike runs like a moped
Reply #19 -
06/04/09 at 04:31:45
dimple goes down.
Back to top
Gargle, sputter, burp and die!!! The ways of my LS650!!!!!
IP Logged
diamond jim
Serious Thumper
Offline
Posts: 1425
North Alabama
Gender:
Re: white spacer mod, now bike runs like a moped
Reply #20 -
06/04/09 at 04:58:47
Yep, down.
Here's a pic just before installing the plate.
Here it is with the plate correctly installed.
You know, I'm not so sure now if the plate can be installed incorrectly. Kinds looks like the screw holes aren't quite placed in the same spot on each side.
And, nearly everyone does this mod yet I don't recall anyone reporting back that they had problems and found they had installed the plate backwards somehow. Whoever opens their carb up next can verify this for us.
Back to top
IP Logged
Reelthing
Serious Thumper
Alliance Member
Offline
Fish or ride that is
the question
Posts: 5397
Houston,Tx
Gender:
Re: white spacer mod, now bike runs like a moped
Reply #21 -
06/04/09 at 05:30:49
Quit easy for the spring to slip off to one side when re-installing the diaphram cover - using a clean thin putty knife to hold down the spring while you put the cover in place might be helpful. Yes if it slips off the center of the plate it will prevent the slide from opening up and produce a moped
If the #4 washers are too big just put them on a long bolt held in place with a nut - put the bolt in a drill and turn them down to size against the garage floor - instant redneck lathe
Back to top
IP Logged
Joshua
YaBB Newbies
Offline
SuzukiSavage.com
Rocks!
Posts: 33
Re: white spacer mod, now bike runs like a moped
Reply #22 -
06/04/09 at 06:44:43
Thanks for all the replies. I guess I'll take the top off the carb and make sure the springs good. I'm almost positive I installed the little plate correctly.
Back to top
IP Logged
Joshua
YaBB Newbies
Offline
SuzukiSavage.com
Rocks!
Posts: 33
Re: white spacer mod, now bike runs like a moped
Reply #23 -
06/04/09 at 09:34:59
So the spring was jacked and I corrected it. That took care of the moped thing but I'm still getting backfire on deceleration and shutdown. Does that mean I should put in/take out another washer?
Back to top
IP Logged
srinath
Serious Thumper
Offline
I love YaBB 1G -
SP1!
Posts: 5349
Re: white spacer mod, now bike runs like a moped
Reply #24 -
06/04/09 at 09:38:28
Open the air screw 1/2 turn.
In some cases that back fire on shut throttle is a feature ...
Cool.
Srinath.
Back to top
IP Logged
dasch
Serious Thumper
Offline
SuzukiSavage.com
Rocks!
Posts: 1137
Re: white spacer mod, now bike runs like a moped
Reply #25 -
06/04/09 at 10:28:01
Fart is cool!!
Back to top
IP Logged
John_D FSO
Serious Thumper
Offline
Ridin' and smilin'
Posts: 1658
Vancouver, WA
Gender:
Re: white spacer mod, now bike runs like a moped
Reply #26 -
06/04/09 at 13:30:47
dasch wrote
on 06/04/09 at 10:28:01:
Fart is cool!!
An attitude I can sympathize with. After my white spacer mod and new exhaust I now have hardly any pop on shutdown, more of a little burp/gurgle. I do however have a real nice snap when I wind it a little and let off, or after rapid upshifts. Not so much on just decel though. As long as it's not running way rich or lean, I kinda like it!
Back to top
'07 ElectraGlide.
IP Logged
T Mack 1 - FSO
Serious Thumper
Alliance Member
Offline
sold 2001 LS650 for
a 1986 XLH1100
Posts: 2919
Emmaus,Pa
Gender:
Re: white spacer mod, now bike runs like a moped
Reply #27 -
06/04/09 at 13:42:52
Make sure the washers you used fit into the hole down in the slide. If they don't , you'll lean out your mid-range preformance.
And, make sure the washers are on the correct side of the needle and spring . If the washers are on the wrong side you'll be real rich.... trust me on this one.....
Back to top
Engineers design things, Technicians make them work.
---
30% of being mechanical is confidence/30% is knowing to go slow when needed/30% is looking repeatedly at what you have/10% is dumb luck
IP Logged
Pages:
1
2
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
09/27/24 at 08:25:19
›
General Category
›
Rubber Side Down!
› white spacer mod, now bike runs like a moped
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.