Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Engine cut off while riding
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages: 1
Engine cut off while riding (Read 168 times)
yumi
Junior Member
Offline
2004 Purple
Posts: 57
gainesville, fl
Gender:
Engine cut off while riding
05/27/09 at 09:32:16
I bought an 04 Savage just over a month ago and have been riding it every other day, save the past week because of all the rain. So today I start her up and ride through town for about 4 miles before heading off to the highway to cruise around. After about 9 miles on the highway, at about 70mph, she slips down two gears and cuts off. I tried to start her back up while coasting but didn't work, so I pulled over and tried again but it just turned over quickly and wouldn't start with wot nor choke. Waited ten minutes, still wouldn't start. Waited another ten and put it on prime for a couple of seconds, she started up as normal and I got home just fine. Can anyone tell me what happened? The bike has cut off once before while riding, but after filling up with gas it hasn't happened again. This time theres plenty of gas.
Back to top
IP Logged
marshall13
Senior Member
Offline
the first step is to
admit your ignorance
Posts: 301
Fort Lauderdale FL
Gender:
Re: Engine cut off while riding
Reply #1 -
05/27/09 at 10:01:38
putting her on prime cured it, there's your clue... the vac line to the petcock is your first culprit to eyeball... the factory one is cheapo cheesy.... id pull and inspect the vac line, if that showed no dice, id check the diaphram in the petcock.... if no obvious culprit showed by then, id be looking at the petcock strainer....fuel starvation without a doubt...
Back to top
IP Logged
verslagen1
YaBB Moderator
ModSquad
Offline
Where there's a
will, I want to be
in it.
Posts: 28889
L.A. California
Gender:
Re: Engine cut off while riding
Reply #2 -
05/27/09 at 11:30:57
The petcock is pretty sensitive to leaks. A little crack will cause it to turn off. Or loose ends. Tye wrap or use hose clamps to secure the hose if it's even alittle bit loose. You'll notice it 1st going up a long uphill grade where you are running close to WOT cause vacuum is minimum at this time.
also, you need to check the hose for gas. The petcock diapham tends to go bad after a few years leaking gas into your intake. If it gets bad enough, it can leak into your engine and into the crankcase. If you ride with gas mixed into your oil you can ruin the engine quite quickly.
So something to add to your monthly check out.
Back to top
Versey's Place
Tech Section Index
IP Logged
Duane
Senior Member
Offline
Creatively
Maladjusted
Posts: 335
Terra Plane
Gender:
Re: Engine cut off while riding
Reply #3 -
05/27/09 at 11:32:33
I wish there was a easy swap for a regular petcock. I don't miss turning it off when I stop but I'm always afraid that the factory one will fail on me.
Back to top
Conformity is the jailer of freedom and the enemy of growth. JFK
IP Logged
Yonuh Adisi FSO
Serious Thumper
Offline
Savage Jedi (Knight)
Posts: 3622
Pilot Valley NV, aka Tatooine
Gender:
Re: Engine cut off while riding
Reply #4 -
05/27/09 at 11:35:23
Duane wrote
on 05/27/09 at 11:32:33:
I wish there was a easy swap for a regular petcock. I don't miss turning it off when I stop but I'm always afraid that the factory one will fail on me.
Search Raptor petcock.
Back to top
Check out Flight of Destiny
http://www.amazon.com/dp/B00H9130XC
IP Logged
Duane
Senior Member
Offline
Creatively
Maladjusted
Posts: 335
Terra Plane
Gender:
Re: Engine cut off while riding
Reply #5 -
05/27/09 at 11:45:11
The Yamaha 350? It that a direct swap?
Back to top
Conformity is the jailer of freedom and the enemy of growth. JFK
IP Logged
Yonuh Adisi FSO
Serious Thumper
Offline
Savage Jedi (Knight)
Posts: 3622
Pilot Valley NV, aka Tatooine
Gender:
Re: Engine cut off while riding
Reply #6 -
05/27/09 at 11:53:14
Many folks around here on this board have done the swap and according to them, yes, the Raptor is a direct swap with the Savage petcock. It is an on-off-reserve petcock unlike the Savage which is Prime-on-reserve.
Use the search function, type in Raptor Petcock and set it to all posts and you should get a truck load of hits.
I personally do not use it because I went with a Road King tank so I am using the Harley petcock. But there is very good results reported on the Raptor.
Back to top
Check out Flight of Destiny
http://www.amazon.com/dp/B00H9130XC
IP Logged
prechermike
Serious Thumper
Alliance Member
Offline
Kalashna Kitty, from
Skat
Posts: 1190
Ponzer, NC
Gender:
Re: Engine cut off while riding
Reply #7 -
05/27/09 at 12:05:12
I did the raptor petcock change soon after I got my bike, the diaphragm failed. It is a direct and easy bolt on. Take the old one off and put the new one on. Nothing more to it.
Back to top
2006, HD pipe, Tkat fork brace, elkhide handgrips, gel seat w/riser, silverblue, Ed L's forward controls, Wristwatch, biblethumper650@gmail.com
IP Logged
Seth C.
Full Member
Offline
Posts: 173
Tucson, AZ
Gender:
Re: Engine cut off while riding
Reply #8 -
05/27/09 at 12:06:39
Rapter 660 I believe. That's what I installed at the suggestion of this board and I couldn't be happier. I like having control (for sure) of my fuel. Just remember to plug the vacume line on your stock carb.
Back to top
2001 Suzuki Savage LS650
IP Logged
yumi
Junior Member
Offline
2004 Purple
Posts: 57
gainesville, fl
Gender:
Re: Engine cut off while riding
Reply #9 -
05/27/09 at 12:22:25
Thanks marshall and verslagen for the leads. I have to wait until my boyfriend gets home because he likes to do all the dirty work. He thinks that it could also be that I am low on fuel, but I have about a quarter tank and it wouldn't start on reserve either. Does anyone else think that low fuel is part of the problem? How low have you run your bike without any problems?
Back to top
IP Logged
Duane
Senior Member
Offline
Creatively
Maladjusted
Posts: 335
Terra Plane
Gender:
Re: Engine cut off while riding
Reply #10 -
05/27/09 at 12:28:02
Fuel is the problem, most likely the petcock I would bet.
Back to top
Conformity is the jailer of freedom and the enemy of growth. JFK
IP Logged
Kropatchek
Serious Thumper
Offline
Why more than 1
cylinder?
Posts: 1457
Alphen a/d Rijn Netherlands
Gender:
Raptor Fuelc0ck
Reply #11 -
05/28/09 at 07:46:36
Found some good pictures of sayd c0ck and partnumbers
( stolen from the Dutch Forum)
Hope the pictures are woth more than words
Back to top
Never ask your bike to scream before her throat is warm.
'93 Sav in '96 ( yellow) looks
IP Logged
Duane
Senior Member
Offline
Creatively
Maladjusted
Posts: 335
Terra Plane
Gender:
Re: Engine cut off while riding
Reply #12 -
05/28/09 at 10:32:48
Nice pics, looks easy. I might do that one the next time I just want to do something to my bike.
Back to top
Conformity is the jailer of freedom and the enemy of growth. JFK
IP Logged
tomtaz1975
YaBB Newbies
Offline
Let's Ride!
Posts: 34
Milwaukee, WI
Gender:
Re: Engine cut off while riding
Reply #13 -
05/28/09 at 10:38:59
Just curious...does this also make it easier to remove the tank?
MY01, like most I believe, is a REALLY tight fit to remove the tank with the petcock attached...
Back to top
2001, Yellow, Dunstall Megaphone Long, 155 Main, 55 Pilot, no spacer, K&N Filter.
IP Logged
Moofed
Full Member
Alliance Member
Offline
...and the engine
just gleams...
Posts: 148
Bloomington, Indiana
Gender:
Re: Engine cut off while riding
Reply #14 -
05/28/09 at 12:06:34
Yes,
much
easier to remove the tank. That's probably why who ever took those pics went to the trouble of making an animated comparison.
Back to top
IP Logged
Pages: 1
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
10/02/24 at 09:26:34
›
General Category
›
Rubber Side Down!
› Engine cut off while riding
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.