SuzukiSavage.com - Carb lines go where?

Welcome, Guest. Please Login or Register :: View Members

SuzukiSavage.com › General Category › Rubber Side Down! › Carb lines go where?

(Moderators: verslagen1, Dave, Serowbot)

‹ Previous topic | Next topic ›

Pages: 1

Carb lines go where? (Read 64 times)

NewB

YaBB Newbies

Offline

SuzukiSavage.com
Rocks!

Posts: 8

Carb lines go where?
09/29/08 at 12:56:19

I have the manual and am pretty good at following schematics and breakdowns, but this doesn't give you much to work with. Rather than trial and ERROR it I figured I would become a member and ask the experts. I took the carb off to clean and thought I could remember where everything went. Any help would be greatly appreciated. Iam calling the hoses 1,2 on the choke side and 3,4,and 5 on the other going from top to bottom left to right, on the petcock lets call em A and B top to bottom

IP Logged

T Mack 1 - FSO

Serious Thumper
Alliance Member

Offline

sold 2001 LS650 for
a 1986 XLH1100

Posts: 2919
Emmaus,Pa
Gender: male

Re: Carb lines go where?
Reply #1 - 09/29/08 at 13:52:25

On Carb,
- Vents, two smaller brass little pipes pointing diagonally up & back towards the seat, one each side, connects to two small hoses that go up into the frame (not connected to anything), unless you have a CA model then they go to the cannister.
- Vacuum port for petcock, brass pipe on right side (clutch side).
- Fuel inlet, brass pipe on left side ( shifter side)

On Petcock,
- pipe on side facing to the rear, is fuel out.
- pipe on back of petcock face diagonally down, is the vacuum port, connects to the right side of carb.

Engineers design things, Technicians make them work.
---
30% of being mechanical is confidence/30% is knowing to go slow when needed/30% is looking repeatedly at what you have/10% is dumb luck Wink

IP Logged

verslagen1

YaBB Moderator
ModSquad

Offline

Where there's a
will, I want to be
in it.

Posts: 28884
L.A. California
Gender: male

Re: Carb lines go where?
Reply #2 - 09/29/08 at 20:39:58

T Mack 1 - FSO wrote on 09/29/08 at 13:56:21:

On Carb,
- Vents, two smaller brass little pipes pointing diagonally up & back towards the seat, one each side, connects to two small hoses that go up into the frame (not connected to anything), ~~unless you have a CA model then they go to the cannister.~~
- Vacuum port for petcock, brass pipe on right side (clutch side).
- Fuel inlet, brass pipe on left side ( shifter side)
- On CA model, there's one more port, right rear, small, goes to canister.

On Petcock,
- pipe on side facing to the rear, is fuel out. (Ø5/16)
- pipe on back of petcock face diagonally down, is the vacuum port, connects to the right side of carb. (Ø3/16)

Corrections

Versey's Place
Tech Section Index

IP Logged

NewB

YaBB Newbies

Offline

SuzukiSavage.com
Rocks!

Posts: 8

Re: Carb lines go where?
Reply #3 - 10/01/08 at 15:18:43

Thank you very much. Glad I stumbled upon my own message. I did not receive any message that anyone replied to my post. I was trying to figure this out this past weekend when the site was having server problems. Now that it is back at full speed I typed carb in the search bar and my post was the second one. I apologize if there is already a post about this subject, it was just impossible to look this past weekend with pages taking 10 miinutes to load.

IP Logged

NewB YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 8	Re: Carb lines go where? Reply #4 - 10/01/08 at 15:32:38 I must have the CA model cause there are 5 ports 2 on left and 3 on right. Since I live in TN is there anything I can do to improve performance by removing this canister?
Back to top	IP Logged

NewB YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 8	Re: Carb lines go where? Reply #5 - 10/01/08 at 15:50:14 I apologize one more time for not understanding but all the ports look to be a copperish brass color. I got the left side, one is fuel and other is going to canister. The right side, is a little foggy they are all similar in size.
Back to top	IP Logged

Yonuh Adisi FSO Serious Thumper Offline Savage Jedi (Knight) Posts: 3622 Pilot Valley NV, aka Tatooine Gender:	Re: Carb lines go where? Reply #6 - 10/01/08 at 16:11:33 Check out this thread. http://suzukisavage.com/cgi-bin/YaBB.pl?board=tech;action=display;num=1098869040
Back to top	Check out Flight of Destiny http://www.amazon.com/dp/B00H9130XC IP Logged

Pages: 1

‹ Previous topic | Next topic ›

« Home