Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Won't start, won't run... help! (Fixed!)
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages:
1
2
3
Won't start, won't run... help! (Fixed!) (Read 406 times)
ZeroStar
YaBB Newbies
Offline
Posts: 38
Port Townsend, WA
Gender:
Won't start, won't run... help! (Fixed!)
08/18/08 at 12:34:53
So I went on vacation for 2 weeks. Left my bike in the garage. When I went to start it this morning, it started really hard, and was acting like it wasn't getting enough gas. I let it idle for a bit with the throttle cranked to keep it alive for what I thought was sufficient warm up. Started down my driveway... putt putt dead. Spent the next hour trying to start it again with no luck (obviously not constant, I let it sit for intervals of time in case it was flooded, etc). Finally had my dad come and help me push it down the driveway for a rolling start. Got it running, and made it halfway around the block before it died, once again acting like it was starving for gas even though the throttle was almost full open. The gas tank is about half full, choke doesn't seem to make a difference... any ideas?
Also, I'm mechanically retarded, and have only had the bike for about 2 weeks before going on vacation so I'm completely at a loss.
Back to top
«
Last Edit: 08/22/08 at 12:37:52 by ZeroStar
»
'04 Silver Savage
IP Logged
mornhm - FSO
Serious Thumper
Offline
HMMM
Posts: 1105
Gender:
Re: Won't start, won't run... help!
Reply #1 -
08/18/08 at 12:43:44
I would suggest checking the battery and connections before going any further.
Back to top
IP Logged
verslagen1
YaBB Moderator
ModSquad
Offline
Where there's a
will, I want to be
in it.
Posts: 28884
L.A. California
Gender:
Re: Won't start, won't run... help!
Reply #2 -
08/18/08 at 12:45:13
Try it on prime, check for gas in the vac line.
had it for 2 weeks, sat for 2 weeks, may have needed a carb clean when you got it, also gas could be stale, drain and replace.
Back to top
Versey's Place
Tech Section Index
IP Logged
ZeroStar
YaBB Newbies
Offline
Posts: 38
Port Townsend, WA
Gender:
Re: Won't start, won't run... help!
Reply #3 -
08/18/08 at 12:51:04
Tried getting to the battery, but the diagrams in the owners manual are useless, and I can't figure out how to get the seat off.
As for vac lines and whatnot, I don't even know what that is, let alone how to check for gas in one...
Sorry for the lack of knowledge
Back to top
'04 Silver Savage
IP Logged
DJM
Full Member
Offline
'06 Red S40
Posts: 116
Encinitas CA
Gender:
Re: Won't start, won't run... help!
Reply #4 -
08/18/08 at 13:04:12
Sounds like a clogged fuel filter to me.
Back to top
Oh, so they have internet on computers now!
IP Logged
eanon
Full Member
Offline
Thump-Thump-Thu mp
Posts: 219
Austin, Texas
Gender:
Re: Won't start, won't run... help!
Reply #5 -
08/18/08 at 13:06:02
The seat comes off with two screws, one on each side, towards the back of the seat. Look under the lower lip of the seat.
Back to top
Red '97, cone filter, 150 main, 52.5 Pilot, half spacer, Screaming Eagle turnout, 17/43 chain drive, shield, de-badged, 4" forward control extensions. Gettin' there.
IP Logged
Yonuh Adisi FSO
Serious Thumper
Offline
Savage Jedi (Knight)
Posts: 3622
Pilot Valley NV, aka Tatooine
Gender:
Re: Won't start, won't run... help!
Reply #6 -
08/18/08 at 13:10:40
ZeroStar wrote
on 08/18/08 at 12:51:04:
Tried getting to the battery, but the diagrams in the owners manual are useless, and I can't figure out how to get the seat off.
As for vac lines and whatnot, I don't even know what that is, let alone how to check for gas in one...
Sorry for the lack of knowledge
There are two 10 mm bolts, one on each side of the seat just forward of the rear shocks. The battery is behind the chrome cover on the left side that is removed with your ignition key. Under that is the tool box plate, three phillips head screws remove that (one on top, two at the bottom) and there is the battery.
The vacuum line is a little rubber hose usually with a spring around it that goes from your petcock (gas valve) to the carburetor. To check for fuel in it, you just unplug it from the carb and see if any gas comes out of it.
Back to top
Check out Flight of Destiny
http://www.amazon.com/dp/B00H9130XC
IP Logged
bill67
Serious Thumper
Offline
old tired
Posts: 8517
genoa city wisconsin
Gender:
Re: Won't start, won't run... help!
Reply #7 -
08/18/08 at 13:11:37
Try some Seafoam in the carb. to clean it up, put the Seafoam in gas tank I had a GR 650 motorcycle for over 20 years drove it once a year about 5 miles never had the carb apart and it still ran good have the five mile clean up with seafoam in the gas tank.
be sure battery is charged up
Back to top
william h krumpen
IP Logged
Serowbot
YaBB Moderator
ModSquad
Offline
OK.... so what's the
speed of dark?
Posts: 28642
Tucson Az
Gender:
Re: Won't start, won't run... help!
Reply #8 -
08/18/08 at 13:24:29
are you using the choke to start it?
Back to top
Ludicrous Speed !... ...
...
IP Logged
verslagen1
YaBB Moderator
ModSquad
Offline
Where there's a
will, I want to be
in it.
Posts: 28884
L.A. California
Gender:
Re: Won't start, won't run... help!
Reply #9 -
08/18/08 at 13:50:32
When removing the battery, the terminals are visible on either side of the bike.
Remove the negative terminal first, that way when you remove the positive there's no chance to short to the frame.
A clymers manual will really help you out, get one for reffering to while working on the bike. Also there's one online, check the tech section.
Back to top
Versey's Place
Tech Section Index
IP Logged
ZeroStar
YaBB Newbies
Offline
Posts: 38
Port Townsend, WA
Gender:
Re: Won't start, won't run... help!
Reply #10 -
08/18/08 at 14:13:52
Thanks for the input all. I'm beginning to think this might be a bit above my abilities and I should take it to the friendly neighborhood bike shop tomorrow...
Back to top
'04 Silver Savage
IP Logged
ZeroStar
YaBB Newbies
Offline
Posts: 38
Port Townsend, WA
Gender:
Re: Won't start, won't run... help!
Reply #11 -
08/18/08 at 14:14:33
Serowbot wrote
on 08/18/08 at 13:24:29:
are you using the choke to start it?
I tried it both ways, similar result.
Back to top
'04 Silver Savage
IP Logged
ZeroStar
YaBB Newbies
Offline
Posts: 38
Port Townsend, WA
Gender:
Re: Won't start, won't run... help!
Reply #12 -
08/18/08 at 14:31:12
Yonuh Adisi FSO wrote
on 08/18/08 at 13:10:40:
The vacuum line is a little rubber hose usually with a spring around it that goes from your petcock (gas valve) to the carburetor. To check for fuel in it, you just unplug it from the carb and see if any gas comes out of it.
Ok, I've found this line, but it seems to be very firmly attached, without damaging it, how do I get it off?
Back to top
'04 Silver Savage
IP Logged
verslagen1
YaBB Moderator
ModSquad
Offline
Where there's a
will, I want to be
in it.
Posts: 28884
L.A. California
Gender:
Re: Won't start, won't run... help!
Reply #13 -
08/18/08 at 15:19:15
Check to see if there's a little wire clamp.
Use a pair of pliers to enlarge it and move it off the nipple.
If still stuck, get a grip with fingers and twist.
If still stuck, use pliers but try not to tear up the hose.
If still stuck, try and push the hose off.
Usally the 1st way works, but they can be stubborn to the point of just cutting it off when they're completely hard.
Back to top
Versey's Place
Tech Section Index
IP Logged
ZeroStar
YaBB Newbies
Offline
Posts: 38
Port Townsend, WA
Gender:
Re: Won't start, won't run... help!
Reply #14 -
08/18/08 at 16:20:47
Ok, battery connections are good (clean and connected).
No gas in the line between fuel switch and carb.
What else should I look at before paying someone else to solve this?
Back to top
'04 Silver Savage
IP Logged
Pages:
1
2
3
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
09/23/24 at 06:31:26
›
General Category
›
Rubber Side Down!
› Won't start, won't run... help! (Fixed!)
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.