Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Fuel problem after sitting and at highway speed
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages:
1
2
Fuel problem after sitting and at highway speed (Read 318 times)
JakeB
Junior Member
Offline
I love YaBB 1G -
SP1!
Posts: 76
NE Ohio
Gender:
Fuel problem after sitting and at highway speed
12/22/07 at 18:46:11
Hi all,
In July I started having a fuel problem with my savage. If it sat for about a week or so without being started the fuel in the external filter would drain out (no drips on floor and no fuel in crankcase) and the bike wouldn't start unless I pulled the gas cap and pressurized the tank to force fuel into the carb. I have a manual converted petthingy and it was in the "off" position while sitting.
Then while riding at about 60-65 mph on a flat road with air temp between 75-80F the bike began to sputter like it was running out of fuel so I switched to reserve but the bike still stalled. While on the side of the road I noticed that there was no fuel in the fuel filter so I took off the gas cap and pressurized the tank forcing fuel into the carb and it was fine till I got home.
Is this a problem with my gas cap not allowing air into the tank or my petthingy leaking air into the fuel line while in "off" position? I noticed the similar "Bizzar" thread but I don't believe it's the same problem because it was not cold at the time and I have a manual petthingy.
Thanks,
JakeB
Back to top
IP Logged
gj859
Full Member
Alliance Member
Offline
I love YaBB 1G -
SP1!
Posts: 158
winchester ky
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #1 -
12/22/07 at 18:51:26
I'm new to Jake, but did you hear a sucking sound when you removed the gas cap?
Back to top
We're at the mercy of time, and time don't got no mercy.
IP Logged
JakeB
Junior Member
Offline
I love YaBB 1G -
SP1!
Posts: 76
NE Ohio
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #2 -
12/22/07 at 19:04:44
Nope, no sucking noises when I pulled the gas cap. When I fill the tank and staraighten the bike up I can hear the gas pushing air out through the cap, so it seems like the cap would allow air to replace fuel as it is being used. Unless there is something in the cap acting as a reed valve.
Thanks,
Jake B
Back to top
IP Logged
Reelthing
Serious Thumper
Alliance Member
Offline
Fish or ride that is
the question
Posts: 5397
Houston,Tx
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #3 -
12/22/07 at 19:11:02
have you had a look at the float? most often they stick open - but that's the only valve left if you manual mod on the petc0ck
Back to top
IP Logged
JakeB
Junior Member
Offline
I love YaBB 1G -
SP1!
Posts: 76
NE Ohio
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #4 -
12/22/07 at 19:18:18
No, I haven't looked at the float yet. That would make sense for the problem at highway speed, but not sure how it would cause the problem while sitting.
Thanks,
JakeB
Back to top
IP Logged
Reelthing
Serious Thumper
Alliance Member
Offline
Fish or ride that is
the question
Posts: 5397
Houston,Tx
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #5 -
12/22/07 at 19:24:07
might be stickin hard closed - could just whack the bowl a couple times with it does this and see if it fills up
Back to top
IP Logged
JakeB
Junior Member
Offline
I love YaBB 1G -
SP1!
Posts: 76
NE Ohio
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #6 -
12/22/07 at 19:30:51
I'll try that tomorrow, hopefully it helps. I put a cheap fuel filter from Autozone on it around the same time the problem started. Do you think the filter could have a leak small enough to leak air but not gas?
Thanks,
Jake
Back to top
IP Logged
Reelthing
Serious Thumper
Alliance Member
Offline
Fish or ride that is
the question
Posts: 5397
Houston,Tx
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #7 -
12/22/07 at 19:37:30
should flow gas anyway - if that tank is full there's enough presure to pour out pretty strong - unless the petc0ck is acting strange
Back to top
IP Logged
gj859
Full Member
Alliance Member
Offline
I love YaBB 1G -
SP1!
Posts: 158
winchester ky
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #8 -
12/22/07 at 19:38:12
Please don't think I'm trying to be a smartalec but maybe you should take the fuel filter out of the system and see if that helps.
Back to top
We're at the mercy of time, and time don't got no mercy.
IP Logged
Reelthing
Serious Thumper
Alliance Member
Offline
Fish or ride that is
the question
Posts: 5397
Houston,Tx
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #9 -
12/22/07 at 19:38:57
your gas line just goes pretty much straight down right?
Back to top
IP Logged
JakeB
Junior Member
Offline
I love YaBB 1G -
SP1!
Posts: 76
NE Ohio
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #10 -
12/22/07 at 19:48:39
Yes, the gas line goes pretty much straight down. Also there was a fuel filter on it before and never had any trouble with it. I could try putting the old filter back on pretty easily. If I have some fuel line laying around I will try completely removing the filter. Thanks for all the ideas so far. Hopefully it will be warm enough tomorrow to go for a ride.
Thanks,
Jake
Back to top
IP Logged
Reelthing
Serious Thumper
Alliance Member
Offline
Fish or ride that is
the question
Posts: 5397
Houston,Tx
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #11 -
12/22/07 at 20:00:48
NE Ohio! - some of that frozen stuff around there I would think -
if you have a case where there is no gas in the filter (assume it's glass?) and the petc0ck is on - if you take the line off the carb does
gas start to run out of the line? - if so it's a stuck float or needle - if not it's futher up the path
Back to top
IP Logged
T Mack 1 - FSO
Serious Thumper
Alliance Member
Offline
sold 2001 LS650 for
a 1986 XLH1100
Posts: 2919
Emmaus,Pa
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #12 -
12/22/07 at 20:02:03
Replace the filter.
Had this problem on my sons Rupp mini-bike, which is also a gravity flow system. The filter gets just enough fine dirt in it that it causes a restriction. Then it doesn't let the air that is in the line go either back to the tank or in to the carb. THat's why you had to pressurize the tank. I'm not 100% sure, but it might be call "air locked".
Note: changing the filter is cheap. Do the cheap things first!!!
Back to top
Engineers design things, Technicians make them work.
---
30% of being mechanical is confidence/30% is knowing to go slow when needed/30% is looking repeatedly at what you have/10% is dumb luck
IP Logged
JakeB
Junior Member
Offline
I love YaBB 1G -
SP1!
Posts: 76
NE Ohio
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #13 -
12/22/07 at 20:15:44
Reelthing,
It was actually in the 40s today and hasn't snowed for a week so the weather isn't too horrible for riding. I think your right about the stuck float and I will confirm that tomorrow.
T Mack,
Had the same thought but the filter was only on there for a month at most before I started having the problem. If the float isn't stuck I will try running the old filter and no filter and if that fixes it I will replace the filter.
Thanks,
JakeB
Back to top
IP Logged
bill67
Serious Thumper
Offline
old tired
Posts: 8517
genoa city wisconsin
Gender:
Re: Fuel problem after sitting and at highway spee
Reply #14 -
12/22/07 at 20:43:58
Take off the filter and put it back the way suzuki made it and your problems will be over.
Back to top
william h krumpen
IP Logged
Pages:
1
2
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
09/23/24 at 08:34:18
›
General Category
›
Rubber Side Down!
› Fuel problem after sitting and at highway speed
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.