Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Engine shuts off when I start revving.
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages: 1
Engine shuts off when I start revving. (Read 2 times)
dr_laxative
YaBB Newbies
Offline
I love YaBB 1G -
SP1!
Posts: 10
Engine shuts off when I start revving.
06/11/07 at 09:50:53
I left this morning for work, got all the way to the end of the block with no problems when all of sudden my engine dies.
The engine only dies when I start letting go of the clutch and I start twisting the throttle. When I start the engine I can twist the throttle once or twice but right after that it just dies when I turn it.
I've tried to see if it was the side stand sensor but I ruled that out by turning the engine on in neutral with the stand down and up and in first gear with the stand is up and it turns on every time.
Any ideas as to what this could be?
Back to top
IP Logged
dr_laxative
YaBB Newbies
Offline
I love YaBB 1G -
SP1!
Posts: 10
Re: Engine shuts off when I start revving.
Reply #1 -
06/11/07 at 09:57:14
Oops maybe I should have put a ,little more info.
I have the 2005 model.
The battery is brand new, only a month old.
Last oil change was 4000km ago.
Back to top
IP Logged
justin_o_guy
Ex Member
Re: Engine shuts off when I start revving.
Reply #2 -
06/11/07 at 11:12:20
My 05 S40 pulled about the same stunt on me. Had under 5,000 miles on it, but close to it. It would last about 5 or 10 minutes then just cut out & it might take 10 minutes before the starter would even engage. Yours starts right back up or what?
Back to top
IP Logged
dr_laxative
YaBB Newbies
Offline
I love YaBB 1G -
SP1!
Posts: 10
Re: Engine shuts off when I start revving.
Reply #3 -
06/11/07 at 11:16:58
justin_o_guy wrote
on 12/31/69 at 16:00:06:
My 05 S40 pulled about the same stunt on me. Had under 5,000 miles on it, but close to it. It would last about 5 or 10 minutes then just cut out & it might take 10 minutes before the starter would even engage. Yours starts right back up or what?
Mine no longer works, as soon as I pull the throttle and let go of the clutch it shuts off.
Back to top
IP Logged
justin_o_guy
Ex Member
Re: Engine shuts off when I start revving.
Reply #4 -
06/11/07 at 11:26:54
So, when the clutch is released, the thing dies. I would short around the clutch switch. You can just pop the connector & jam a piece of paper clip in there to see if thats gonna get it. If so, do whatevr you like, make it permanent.
Back to top
IP Logged
justin_o_guy
Ex Member
Re: Engine shuts off when I start revving.
Reply #5 -
06/11/07 at 11:29:44
Waita mnute here. What happens when you are in neutral? IF you can play with the clutch & crank the gas on & off in neutral then its gotta be a safety switch. I bypassed the kickstand switch even tho I couldnt prove it was bad. It still has shafetd me a few times since, but it changed the hassle factor by a ton. My clutch isnt bypassed.
Back to top
IP Logged
Savage_Rob
Serious Thumper
Alliance Member
Offline
Mechanically
Inclined Amateur
Posts: 6972
Texas (Dallas area)
Gender:
Re: Engine shuts off when I start revving.
Reply #6 -
06/11/07 at 11:59:10
That's an excellent question. If you can rev it normally without it dying while in neutral, you can rule out fuel and go electrical.
Back to top
1998|MAC muffler|ceramic coated header|K&N air filter|Amal Mk2 carb|Odyssey battery|iridium plug|NC windshield|Dunlop 491s|Superbrace|EBC brake rotor|12.5" Progressive shocks|Kuryakyn ISO grips
IP Logged
dr_laxative
YaBB Newbies
Offline
I love YaBB 1G -
SP1!
Posts: 10
Re: Engine shuts off when I start revving.
Reply #7 -
06/11/07 at 12:06:53
Savage_Rob wrote
on 12/31/69 at 16:00:06:
That's an excellent question. If you can rev it normally without it dying while in neutral, you can rule out fuel and go electrical.
Hmm I'm not entierly sure I'll have to check that again when I get home. I did fill my tank on Saturday and I tried revving in while on reserve.
Back to top
IP Logged
justin_o_guy
Ex Member
Re: Engine shuts off when I start revving.
Reply #8 -
06/11/07 at 12:17:19
If therre is a question about the health of the oetcock, PRI is the way to check that, The Res & Run work the same using vacuum, just different height inlet tube in the tank.
Back to top
IP Logged
dr_laxative
YaBB Newbies
Offline
I love YaBB 1G -
SP1!
Posts: 10
Re: Engine shuts off when I start revving.
Reply #9 -
06/11/07 at 12:26:54
justin_o_guy wrote
on 12/31/69 at 16:00:06:
If therre is a question about the health of the oetcock, PRI is the way to check that, The Res & Run work the same using vacuum, just different height inlet tube in the tank.
I wish I knew what you meant there...
oetthingy?
res & run ??
using vacuum??
Back to top
IP Logged
verslagen1
YaBB Moderator
ModSquad
Offline
Where there's a
will, I want to be
in it.
Posts: 28884
L.A. California
Gender:
Re: Engine shuts off when I start revving.
Reply #10 -
06/11/07 at 12:55:35
dr_laxative wrote
on 12/31/69 at 16:00:06:
oetthingy?
res & run ??
using vacuum??
oetthingy = petc0ck
res & run = positions of the petc0ck, there's also 'pri'me
using vacuum = vacuum line from carb to petc0ck, used to turn gas on.
Back to top
Versey's Place
Tech Section Index
IP Logged
dr_laxative
YaBB Newbies
Offline
I love YaBB 1G -
SP1!
Posts: 10
Re: Engine shuts off when I start revving.
Reply #11 -
06/11/07 at 13:08:12
verslagen1 wrote
on 12/31/69 at 16:00:06:
oetthingy = petc0ck
res & run = positions of the petc0ck, there's also 'pri'me
using vacuum = vacuum line from carb to petc0ck, used to turn gas on.
Oh okay... I don't think there's anything wrong with my petcock. There's no reason for it to suddenly stop working... I used it on saturday and it was fine.
Back to top
IP Logged
Pages: 1
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
09/21/24 at 09:57:28
›
General Category
›
Rubber Side Down!
› Engine shuts off when I start revving.
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.