SuzukiSavage.com - Print Page

SuzukiSavage.com
/cgi-bin/YaBB.pl
General Category >> The Cafe >> Parts availability
/cgi-bin/YaBB.pl?num=1678279216

Message started by pg on 03/08/23 at 04:40:16

Title: Parts availability
Post by pg on 03/08/23 at 04:40:16

My s40 is 18 years old and I plan on keeping it as long as I can find the parts to keep it on the road. I know they offered the s40 until the late teens; however, at some point parts will be hard to find. Is this correct? OEM parts will be made for about 10 years after the last year the model was manufactured. Then parts will start drying up and ebay will be a good or only resource down the road.

Best regards,

Title: Re: Parts availability
Post by pg on 03/08/23 at 12:19:01

Are these timelines for oem parts correct?

Best regards,

Title: Re: Parts availability
Post by Dave on 03/08/23 at 16:23:26

I would guess that you are about right.....with the current regulations parts are supposed to be provided for 10 years.

However - when the pandemic hit it was nearly impossible to get some Savage parts I had ordered.

The Suzuki Savage is not a motorcycle with a lot of aftermarket parts available - however gaskets, carb jets, seals, and a few other parts can be obtained from other sources than Suzuki. And eBay can be a good source of used parts....or even new parts from folks other than dealers.

At 18 years old I would suspect some of the plastic and rubber parts are starting to show their age. The diaphragms in the carb are likely stiff, the air cleaner hose between the carb and air box is likely getting a bit rigid.....and a few seals may be a bit tired.....and the rather expensive fuel enrichment device is plastic and stops working when the plastic breaks.

It wouldn't hurt to stock up on a few small items like gaskets, seals, the carb diaphragms, etc. The carb diaphragms are available aftermarket on eBay and far cheaper than getting them from Suzuki.

Title: Re: Parts availability
Post by pg on 03/08/23 at 17:30:44

I spent a lot of time this past year fixing & refurbishing multiple parts. It is running better than I can remember. Yes you are correct, I should stock up at some point.

Best regards,