SuzukiSavage.com - Print Page

SuzukiSavage.com
/cgi-bin/YaBB.pl
General Category >> Rubber Side Down! >> Electrical components
/cgi-bin/YaBB.pl?num=1553362913

Message started by cigarandcoffeeman on 03/23/19 at 10:41:53

Title: Electrical components
Post by cigarandcoffeeman on 03/23/19 at 10:41:53

After years of not being able to log onto the site... I'm back :)
My bikes still off the road... Nearly 5 years now...
I have a re-wire to do which I'm about ready to attack as my original loom was buggered.... (It's a 400 not 650, the book doesn't match what's left of my loom) I'm attempting a motogadget install.
A few odds n ends and I should be done... I hope anyway

Can anyone tell me what these wires go to?

Reg/rectifier - red wire and black with white stripe? Black with white stripe I assume is an earth?

Black box- orange and green wire both going into connection?

Starter solenoid- yellow and black wire I think goes to start button, I think black and white stripe is an earth, and black with grey dots goes to the black box?

Ignition switch- red and black striped wire to main fuse then to starter solenoid, brown and grey dotted wire to tail/brake light possibly for parking lights, 2 orange wires?

Any help appreciated

Regards

Mike

Title: Re: Electrical components
Post by cigarandcoffeeman on 03/23/19 at 10:45:48

Title: Re: Electrical components
Post by cigarandcoffeeman on 03/23/19 at 10:46:17

Title: Re: Electrical components
Post by cigarandcoffeeman on 03/23/19 at 10:46:39

Title: Re: Electrical components
Post by cigarandcoffeeman on 03/23/19 at 10:47:05

Title: Re: Electrical components
Post by cigarandcoffeeman on 03/23/19 at 10:48:41

Title: Re: Electrical components
Post by cigarandcoffeeman on 03/23/19 at 10:49:00

Title: Re: Electrical components
Post by verslagen1 on 03/23/19 at 11:02:57

787C767E706C787C79796C150 wrote:

Can anyone tell me what these wires go to?

Reg/rectifier - red wire and black with white stripe? Black with white stripe I assume is an earth?

Black box- orange and green wire both going into connection?

Starter solenoid- yellow and black wire I think goes to start button, I think black and white stripe is an earth, and black with grey dots goes to the black box?

Ignition switch- red and black striped wire to main fuse then to starter solenoid, brown and grey dotted wire to tail/brake light possibly for parking lights, 2 orange wires?

Black with white stripe is ground everywhere.
reg/rec red goes to ig switch
black box I assume is the TDI those would be the timing sensor
starter relay yellow and black goes to starter button, in a stock wiring diagram it goes to the decomp controller.
there is a wire from the starter to the TDI that retards the timing for starting.
ig switch brown wire is to the license plate light.

here's a diagram for ig circuit w/out decomp controller.

http://www.savageriders.com/verslagen/Circuits/96-04-ig-starter.JPG

Title: Re: Electrical components
Post by cigarandcoffeeman on 03/23/19 at 12:45:48

Thanks verslagen,

That has helped a lot!!

On your diagram, the igniter has 2 wires going to the pickup coil? What is that? What does it look like?

Many thanks!

P.s it's good to see your still here, I was 1 of the 1st to order your cam chain tensioner 8-)

Title: Re: Electrical components
Post by verslagen1 on 03/23/19 at 13:28:34

you're pointing to it.
http://suzukisavage.com/yabb2.2/Attachments/IMG_20190323_172859368-868x1157.jpg