SuzukiSavage.com - Print Page

SuzukiSavage.com
/cgi-bin/YaBB.pl
General Category >> Rubber Side Down! >> Hello with vacuum lines
/cgi-bin/YaBB.pl?num=1533064055

Message started by Jokerworld on 07/31/18 at 12:07:35

Title: Hello with vacuum lines
Post by Jokerworld on 07/31/18 at 12:07:35

Hey,

I just got a used 2001 suzuki savage ls650. When I got out it's been sitting since 2015. Also it was in pieces, I have slowly got everything put back together except a few hoses. Two I have figured are vacuum lines that run underneath the air filter box. The one I have no clue about is on the right side of the engine that comes out of the the cap head engine cover.

Abby help would be greatly appreciated.

Title: Re: Hello with vacuum lines
Post by Serowbot on 07/31/18 at 12:44:26

Larger hose from head cover (right-side) is the crankcase vent, it goes to the airbox (left side) behind the carb.
Carb has 4 hoses... left side - fuel from the petcock
right side, angled to front - vacuum to back of petcock
2 small matching at the rear of carb - vent hoses, they attach to nothing (open to air) and are looped up into the frame under the tank.

vent tubes...
http://i600.photobucket.com/albums/tt82/serowbot/vents001.jpg

Title: Re: Hello with vacuum lines
Post by zipidachimp on 07/31/18 at 14:36:21

after you install a Raptor, you'll have zero vacuum lines. 8-)

Title: Re: Hello with vacuum lines
Post by justin_o_guy2 on 07/31/18 at 14:46:05

How many miles?

Title: Re: Hello with vacuum lines
Post by verslagen1 on 07/31/18 at 14:55:45

Are you in California?

Title: Re: Hello with vacuum lines
Post by Jokerworld on 07/31/18 at 17:08:19

Thanks,

140,000 miles

Yes I'm in California

This is my first bike as well

Title: Re: Hello with vacuum lines
Post by verslagen1 on 07/31/18 at 18:16:51

http://www.sherv.net/cm/emoticons/shocked/big-surprise-smiley-emoticon.gif

Cali bikes have a carbon canister under the swingarm... that's where those 2 lines are going.

Title: Re: Hello with vacuum lines
Post by Jokerworld on 07/31/18 at 20:08:41

What is a carbon canister? Do you have a picture of that? I don't see any other canister on the bike or any location for one.

Title: Re: Hello with vacuum lines
Post by batman on 07/31/18 at 22:32:29

It sets on a small shelf that is also part of the bracket the muffler is bolted to. It's, under the trans , just forward of the tire, near the swingarm pivot.(unless it's been removed)