SuzukiSavage.com
/cgi-bin/YaBB.pl General Category >> Rubber Side Down! >> Compression Test /cgi-bin/YaBB.pl?num=1521969318 Message started by DragBikeMike on 03/25/18 at 02:15:18 |
Title: Compression Test Post by DragBikeMike on 03/25/18 at 02:15:18 The LS650 has a solenoid operated compression release for starting. How do you check cranking pressure? Will it hurt the starter or starter drive if I disconnect the compression release temporarily to check cranking pressure? Will it even crank over with the compression release inoperative? |
Title: Re: Compression Test Post by Dave on 03/25/18 at 04:02:58 Disconnect the cable, or remove the arm from the shaft....or unplug the solenoid. Easy Peasy! ;) |
Title: Re: Compression Test Post by DragBikeMike on 03/25/18 at 12:46:55 Sounds good. So I can assume that it won't hurt the starter or starter drive. Many years ago I worked in a Harley shop (early 70's). We had lots of trouble with the little sprint 350. It used a Hitachi starter with a planetary gear drive. Used to regularly see those gear drives disintegrate. I don't want to hurt the little starter on my LS650. Thanks much. |
Title: Re: Compression Test Post by Dave on 03/25/18 at 18:12:57 The case can be broken on the early models......if the engine kicks backward at the shutdown. Later on a torque limiter was installed that allowed slippage if a kick back occurred. Every now and then when I shut my bike off.....I can hear it kick backward and there is a faint whine sound as the engine comes to a stop. |
Title: Re: Compression Test Post by eau de sauvage on 03/25/18 at 20:25:24 Please post the compression test when you have it. I did mine recently and it was only 125 which I cannot believe. Mind you it's difficult to get the adapter into the spark plug socket on this bike so I'm hoping it wasn't sealing properly. 46404F33313632020 wrote:
That's the aermachhi single yeah? I had a '73 model with the red white and blue stripes on a black tank. |
Title: Re: Compression Test Post by DragBikeMike on 03/26/18 at 11:01:27 Yes, the Americhi single. I have fond memories of bump starting the demo every morning to warm it up so the salesmen could get it started when a customer wanted a check out. Whew! I was not fond of the sprint 350. |
Title: Re: Compression Test Post by justin_o_guy2 on 03/26/18 at 12:40:06 If you put it in gear and roll it past tdc, then the starter can get a running start. |
Title: Re: Compression Test Post by eau de sauvage on 03/26/18 at 16:40:09 It was my first bike and it did lasting psychological damage to me that lingers till this very day. It reduced me to tears on many occasions. 45434C30323531010 wrote:
|
SuzukiSavage.com » Powered by YaBB 2.2! YaBB © 2000-2007. All Rights Reserved. |