SuzukiSavage.com /cgi-bin/YaBB.pl General Category >> Rubber Side Down! >> CONTROL UNIT ISSUES /cgi-bin/YaBB.pl?num=1125543933 Message started by CAPTAIN-DISASTER on 08/31/05 at 20:05:33

Title: CONTROL UNIT ISSUES Post by CAPTAIN-DISASTER on 08/31/05 at 20:05:33 Has anyone besides myself had issues w\ the control unit? It is the black box above carb behind gas tank. Sits on a tab where rear frame rails meet main tube. It is a sealed unit & mine had water in it, causing damage to unit. Some symptoms are starter relay engages & drains battery, starter will engage w\ ign off & key out. Will check schematic but I belive it deals w\ at the least the starter relay & compression release. Has anyone eliminated this unit & come up w\ an alternate?

Title: Re: CONTROL UNIT ISSUES Post by Kropatchek on 09/01/05 at 03:05:13 Easiest way is to get another one ( from E-bay). Then open up the one you have and see what's inside. I read in another forum ( German) that it can be repaired by anyone with electronics knowledge. Greetz Kropatchek ;D

Title: Re: CONTROL UNIT ISSUES Post by Greg_650 on 09/01/05 at 06:49:10 CAPTAIN-DISASTER wrote: Has anyone besides myself had issues w\ the control unit? It is the black box above carb behind gas tank. Sits on a tab where rear frame rails meet main tube. It is a sealed unit & mine had water in it, causing damage to unit. Some symptoms are starter relay engages & drains battery, starter will engage w\ ign off & key out. Will check schematic but I belive it deals w\ at the least the starter relay & compression release. Has anyone eliminated this unit & come up w\ an alternate? Yep.  That is the decompression module.  You could eliminate it if you can find a way to rewire the ignition module and the starter relay.

SuzukiSavage.com » Powered by YaBB 2.2! YaBB © 2000-2007. All Rights Reserved.