SuzukiSavage.com - Print Page

SuzukiSavage.com
/cgi-bin/YaBB.pl
General Category >> Rubber Side Down! >> (Another) Electrical Questions
/cgi-bin/YaBB.pl?num=1720916017

Message started by Odysseus on 07/13/24 at 17:13:37

Title: (Another) Electrical Questions
Post by Odysseus on 07/13/24 at 17:13:37

Keepin' on truckin' with the electrical issues....

1. Anyone know what https://i.ebayimg.com/00/s/MTIwMFgxNjAw/z/cbIAAOSwwEhmkxcH/$_57.JPG?set_id=880000500F is and what I can do fix it. There are two clips that slide into two flat posts; unfortunately, I lost a clip as you can see and the wire is too short to trim any further.

2. Should I just get a new one? (I was thinking about getting a new wired started assembly anyway but they are $$$).

3. See that space above the wires? Does something feed out of that? Do I have a hiccup in there somewhere?

4. Do these electrical issues ever go away :P

Title: Re: (Another) Electrical Questions
Post by DragBikeMike on 07/13/24 at 23:17:03

Those would be the wires to your front brake switch. You have them routed incorrectly. They should pass through the empty notch. If you route them correctly, you might have sufficient wire length to replace the connector and get it hooked up.

Like this.

Title: Re: (Another) Electrical Questions
Post by Odysseus on 07/13/24 at 23:55:16

Thanks DBM. Since my wire ripped out of my ~thing that slides onto the post~ thing, is this something I can wrap around the post (there's a little hole in there) and electrical tape it?

Title: Re: (Another) Electrical Questions
Post by DragBikeMike on 07/13/24 at 23:58:03

No. Fix it correctly.

Title: Re: (Another) Electrical Questions
Post by Odysseus on 07/15/24 at 12:12:42

Good deal, thenks DBM. I have a guy with a 2006 S40 harness right side will that fit my 2005 s40? Curious.

Title: Re: (Another) Electrical Questions
Post by ThumperPaul on 07/15/24 at 12:46:43

It will fit.