SuzukiSavage.com - Print Page

SuzukiSavage.com
/cgi-bin/YaBB.pl
General Category >> Rubber Side Down! >> Oil leaking through puke tube
/cgi-bin/YaBB.pl?num=1472434785

Message started by BG8036 on 08/28/16 at 18:39:45

Title: Oil leaking through puke tube
Post by BG8036 on 08/28/16 at 18:39:45

86 ls650 took bike out from sitting foe about week when I pikes it up gas was commin out of air filter box? So I got rag and cleanEd up.went 60 mile, pulled puke plug little oil. Oil lady got on today went for 15 mile ride puke oil all,over drive and burning oil at plug and choking out any ideas. O not lacking power shifts great 2 iam stumped

Title: Re: Oil leaking through puke tube
Post by justin_o_guy2 on 08/28/16 at 18:49:34

Raptor petcock?
Is it
Making oil?

The float might be stuck.
Tap the carburetor..

Others are smarter on this,let's see what they say.

Title: Re: Oil leaking through puke tube
Post by BG8036 on 08/28/16 at 18:56:47

Stock petcock thanks I forgot that, but carb is jetted.

Title: Re: Oil leaking through puke tube
Post by Armen on 08/28/16 at 19:05:53

Gotta say, that post was almost unintelligible.

Title: Re: Oil leaking through puke tube
Post by batman on 08/28/16 at 19:43:27

BG,you need a Yamaha raptor 660 petcock ,then you need to check your oil you may have gas in it,if the level is high take off the fill cap and check the smell.the stock petcock is sending gas down the vacuum line flooding the bike making it "choke".It floods out the carb,the gas can only go two ways out the carb into your air box or into the cylinder past your rings into the crank case with your oil.....as for oil around the plug you need to clean off the motor then restart it to see where it coming from.

Title: Re: Oil leaking through puke tube
Post by justin_o_guy2 on 08/28/16 at 20:39:41

Oil is cheap, just change it. After the problem is solved. And I wouldn't be riding until i got it.
Oil/ Filter, about ten bucks.
Engine?

Title: Re: Oil leaking through puke tube
Post by jcstokes on 08/28/16 at 22:36:23

If you get a Yamaha Raptor 660 petcock, get a proper one and not the cheapest thing on EBAY. People here will advise you the CORRECT part number.

Title: Re: Oil leaking through puke tube
Post by justin_o_guy2 on 08/29/16 at 03:59:07

I just bought one. It's right at thirty bucks. Just walked in, got it. No waiting,

Title: Re: Oil leaking through puke tube
Post by BG8036 on 08/29/16 at 04:24:23

Oil is coming from vent tube of vavle cover vent hose and going to breather box.would the be from oil being to thin?

Title: Re: Oil leaking through puke tube
Post by Dave on 08/29/16 at 04:29:05

20255A525154620 wrote:

Oil is coming from vent tube of vavle cover vent hose and going to breather box.would the be from oil being to thin?

I think you have somehow missed the important information in the above posts. Have you checked your oil level?

The stock petcock can get a hole in the diaphragm, and that can allow fuel to flow down the vent tube, and this fuel can then get into the crankcase can dilute the oil, and it will result in too high of a "oil" level in the crankcase.

Title: Re: Oil leaking through puke tube
Post by BG8036 on 08/29/16 at 04:44:27

Thanx, that was what I was thinking.just wanted to be 100% on same page as everyone else

Title: Re: Oil leaking through puke tube
Post by BG8036 on 09/02/16 at 19:00:53

Fixed petcock changed oil and oil filter, had Alot I mean Alot of gas in oil.lucky dint blow moter or oil seals.how many times should I change it

Title: Re: Oil leaking through puke tube
Post by justin_o_guy2 on 09/02/16 at 19:20:25

Did you leave the plug and fill cap off and let it vent?

Run any air through it?

Heck, I dunno,,
It's got the bath tub in the head, and I don't know how easy it is to evaporate gas off,,
I'm sure someone will join in.

Title: Re: Oil leaking through puke tube
Post by BG8036 on 09/02/16 at 19:22:38

Let it vent for about hr or so I changed it yesterday and oil is all ready blacker then ace of spades

Title: Re: Oil leaking through puke tube
Post by justin_o_guy2 on 09/02/16 at 19:30:38

What oil is it?

Rotella T 15/40
Cheap, excellent, available

You have doubts? Change the oil. It's cheaper than a motor.

Title: Re: Oil leaking through puke tube
Post by justin_o_guy2 on 09/02/16 at 19:34:07

If you want All the oil out, lay it down on the left side a while.

Title: Re: Oil leaking through puke tube
Post by BG8036 on 09/02/16 at 19:46:20

Suzuki 20-50

Title: Re: Oil leaking through puke tube
Post by justin_o_guy2 on 09/02/16 at 20:02:08

Spending more than necessary. I don't know if it's even as good as Rotella .
How much is it a quart?
Rotella T 15-40 is about$13.00 a gallon.

Title: Re: Oil leaking through puke tube
Post by BG8036 on 09/02/16 at 20:17:33

5 bucks a quart where is it 13 a gallon that full syn

Title: Re: Oil leaking through puke tube
Post by KennyG on 09/02/16 at 20:38:53

BG

The full synthetic is a little more money. You can get it cheaper than this, but here is what Amazon charges: https://www.amazon.com/Shell-Rotella-550019921-Synthetic-Diesel/dp/B005CHT4W6/ref=sr_1_1?ie=UTF8&qid=1472873949&sr=8-1&keywords=rotella+t6+5w-40+synthetic

Kenny G

Title: Re: Oil leaking through puke tube
Post by Steve H on 09/03/16 at 12:58:15

Rotella T 15w40 is the dino juice. The synthetic is T6.
They are around $13/gal and $21/gal at Walmart in the auto section.

Title: Re: Oil leaking through puke tube
Post by justin_o_guy2 on 09/03/16 at 13:00:28

People have tons of miles on the Dino, works great, motor love you long time.

Title: Re: Oil leaking through puke tube
Post by Steve H on 09/04/16 at 16:46:40

If your puke tube doesn't have the uphill portion after exiting the engine, it'll cause much more oil to come out. The tube runs uphill to the frame and then to the airbox, I believe. The uphill portion allows a lot of the sprayed out oil to run back down into the engine.

Try routing it with a section going up and then route the end wherever. See if that helps.