SuzukiSavage.com - Print Page

SuzukiSavage.com
/cgi-bin/YaBB.pl
General Category >> Rubber Side Down! >> Choke lever not sticking anymore
/cgi-bin/YaBB.pl?num=1414208389

Message started by ezornes239 on 10/24/14 at 20:39:49

Title: Choke lever not sticking anymore
Post by ezornes239 on 10/24/14 at 20:39:49

So I used to be able to pull my choke out, it'd click in place, then you could pull it out a bit farther and it'd click in place, then you could pull it out all the way. It just stopped staying in place some time this week. It's either full out or it just slides all the way back in. Any ideas on what happened/I did? Thanks.

Title: Re: Choke lever not sticking anymore
Post by Dave on 10/25/14 at 03:16:26

You must have worn it out.

Take it off the carb and see if there is anything that you can fix. If not, you need to order a new one.

Title: Re: Choke lever not sticking anymore
Post by justin_o_guy2 on 10/25/14 at 10:52:33

Stuff that has a spot where it stop[s has some kinda detent setup.. a groove in the shaft and a spring with a BB in a drilled hole aimed into it, or something as simple as a hard piece of strap with a bump bent into it,, but that thing otta be POsitively In {PLace,, If it changed right after you did something,, You mite wanna revisit that..Otherwise, I never went there, so, I dunno how hard it is to get TO the detent on it, But, Id look at it, on the bike and see what I could figure out, if its gonna be an easy fix,, do it there, If not, Id get it on the bench,, Too much little stuff to be trying to work on it on the bike,,

Title: Re: Choke lever not sticking anymore
Post by verslagen1 on 10/25/14 at 15:19:24

just a couple of plastic bumps that goes thru a hole
you wore one of them out.

Title: Re: Choke lever not sticking anymore
Post by justin_o_guy2 on 10/25/14 at 18:42:30

Time for some McGyver stuff,,