SuzukiSavage.com
/cgi-bin/YaBB.pl General Category >> Rubber Side Down! >> Newbie question about drive belt. /cgi-bin/YaBB.pl?num=1335346948 Message started by wambr on 04/25/12 at 02:42:28 |
Title: Newbie question about drive belt. Post by wambr on 04/25/12 at 02:42:28 Hello! guys I have a savage ls 400 '95. I installed the belt instead of the stock chain. When you reset the engine speed on the move appears a sound in the area lead sheave. When I use the clutch, buzz disappears. It is ok? thanks! p.s. sorry for my english. |
Title: Re: Newbie question about drive belt. Post by justin_o_guy2 on 04/25/12 at 03:53:02 Doesnt sound good, flatten the bent over washer & retorque that front sheave, & do it soon, because it will mess the teeth up |
Title: Re: Newbie question about drive belt. Post by wambr on 04/25/12 at 08:29:04 Thank you Justin! I did everything you told me. i retourged nut lead sheave. It has been delayed. No backlashes not found. wear of the splines too. can u give me wrong tense of drive belt? How can this be just check. I have not a tension meter. :( |
Title: Re: Newbie question about drive belt. Post by justin_o_guy2 on 04/25/12 at 08:38:57 WE adjust our by hand, Put it in gear & roll it backwards to put all the slack on the bottom, grab the belt 1/2 way between sheaves, twist the belt. Not gorilla force here, it shouldnt be hard, a secretary should be able to do it,if it will twist about 90 degrees,, thats pretty good. |
Title: Re: Newbie question about drive belt. Post by wambr on 04/25/12 at 10:09:44 I checked the belt tension. I was able to rotate it 90 degrees by hand without much effort. then I rode on my bike for about 15 miles. Buzz, but it's much quieter. How did mattress drive belt? is probably only one reason-set of pulleys and belt were pre-owned? leading the pulley I purchased from another vendor. |
Title: Re: Newbie question about drive belt. Post by justin_o_guy2 on 04/25/12 at 10:17:11 Every time I get mine wet, it squeaks, I put some canning wax on it & that stops it, but it slings it on the wheel,, yukkk,, |
Title: Re: Newbie question about drive belt. Post by Savage_Rob on 04/25/12 at 11:42:05 0A151314090E3F0F3F07151952600 wrote:
Heh, used to use a bar of soap on squeaky car belts. On this one, I just let it squeak until it dries enough to stop on its own. |
Title: Re: Newbie question about drive belt. Post by wambr on 04/26/12 at 11:21:30 Thanks guys! that's just in time showed how to check belt tension http://suzukisavage.com/cgi-bin/YaBB.pl?num=1335401723/0#0 tomorow i'll checked drive belt. i think it's a reason of my small trouble thanks. |
SuzukiSavage.com » Powered by YaBB 2.2! YaBB © 2000-2007. All Rights Reserved. |