SuzukiSavage.com - Print Page

SuzukiSavage.com
/cgi-bin/YaBB.pl
General Category >> Rubber Side Down! >> will it fit?
/cgi-bin/YaBB.pl?num=1334100371

Message started by thumper on 04/10/12 at 16:26:11

Title: will it fit?
Post by thumper on 04/10/12 at 16:26:11

well i just got done rebuilding the top end, it started up just fine and idled perfect but in the midrange it would bog out, so in the midst of getting the carb tuned in it started acting funny, now it wont start unless its wide open and then it still bogs and wont stay running. ended up noticing that the regulater had a burnt up wire. i looked at the wiring diagram and it shows two sets of three wires comming from the regulator. now when i look at the wires there are the three yellow wires for the stator and only two coming frome the other side of the regulator, on the harness there are three, but only conecting into two. also i have a 97 that i think i could pull the regulator from but am unsure if the interchange, any help or advice out be greatly appreciated. thanks yall

Title: Re: will it fit?
Post by justin_o_guy2 on 04/10/12 at 16:28:24

IDK if itll fit, but if it wont, I bet it will blend..

Title: Re: will it fit?
Post by thumper on 04/10/12 at 16:30:18

also i forgot to add that its an 04 that im working on, i had heard that in 04 i think that they changed the wiring for the regulator, maybe mistaken though

Title: Re: will it fit?
Post by thumper on 04/10/12 at 16:42:06

would the regulator being bad make it not run like that? i was thinking that it would run just fine off the battery and the stator and reg was just for keeping the battery charged, im no good at stuff like this lol, just want the darn thing running rite again

Title: Re: will it fit?
Post by thumperclone on 04/10/12 at 21:46:19

SSM 2006
both years 87(covers to 95) and 04 have 6 wire from the regulator/ rectifier..
3 ea Y
O/B,R, B/W
tho in the diagrams they come out at different positions also 87 colors are same after 1st connector in the harness 04 changes colors>
R = R/B
B/W=B/W, O/B=O/B
not seein a decomp selenoid on the 87 diagram

Title: Re: will it fit?
Post by thumper on 04/11/12 at 01:02:49

yes i have seen the wiring diagram and it shows a 6wire rectifier but the on that is on my bike is only a 5 wire and the bike is an 04, this makes no sense.

Title: Re: will it fit?
Post by Routy on 04/11/12 at 07:02:11

Did you touch anything else in your top end rebuild ? If so, look there for the problem. Like said, it should run on the battery.

Title: Re: will it fit?
Post by thumper on 04/11/12 at 10:19:54

new rings and gaskets.