SuzukiSavage.com
/cgi-bin/YaBB.pl General Category >> Rubber Side Down! >> HD Dyna Muffler Issue/Winter Tuning /cgi-bin/YaBB.pl?num=1331072246 Message started by Wake51 on 03/06/12 at 14:17:26 |
Title: HD Dyna Muffler Issue/Winter Tuning Post by Wake51 on 03/06/12 at 14:17:26 So I've been attempting to do a winter tune up on my bike. That includes fixing the exhaust leak with the HD Dyna I have installed. While working on it, I noticed that when I shake the muffler it has a 'sandy' feel in it. I can poor some of what appears to be soot sand out of it after I shake it enough. Is it possible the baffle came loose? If so, are there any performance ramifications and do I need to trash it? I have a replacement on hand if need be. My second issue comes from tuning. I have the HD Dyna muffler on the bike and a none filter. Currently I have a 152.5 Main and 52.5 no vents pilot. I plan on re-jetting to a Main 55. No Vents Pilot. When I start my bike, it revs high for a few seconds before settling to a somewhat inconsistent idle. Is this suggestive of any sort of condition, lean rich or otherwise? I'm not sure why the bike would start with a rev, I insured the throttle is closed and idle screw is adjusted. Carb was cleaned just a couple weeks ago. Thanks for any input. -Wake |
Title: Re: HD Dyna Muffler Issue/Winter Tuning Post by Serowbot on 03/06/12 at 15:39:37 Shake some of that "soot sand" out onto the floor... if a magnet will pick it up,.. yer' muffler is toast.. If not, it's just carbon build-up... Quote:
Huh?... :-?... Revving up then settling at start is not jetting... Do you have a Raptor?... Might have a slow leak that puddles overnight... |
Title: Re: HD Dyna Muffler Issue/Winter Tuning Post by Wake51 on 03/06/12 at 17:58:39 Ment to say 55 pilot. No bleed holes. I do have a raptor installed. |
Title: Re: HD Dyna Muffler Issue/Winter Tuning Post by Wake51 on 03/06/12 at 19:35:24 I put the new jet and pretty much resolved the exhaust leak. I have the idle mixture set to 1.5 turns. When i started it it wanted to cut out and was accompanied by excessive backfiring... |
Title: Re: HD Dyna Muffler Issue/Winter Tuning Post by justin_o_guy2 on 03/06/12 at 20:54:13 I wasnt able to set the idle mix in the shop. Stuck a little screwdriver in my pocket & went for a ride. Once it was warmed up good, & started very slowly, like 1/8th turn, making adjustments at red lights till I got it like I wanted it, it was a decent ride,., |
SuzukiSavage.com » Powered by YaBB 2.2! YaBB © 2000-2007. All Rights Reserved. |