SuzukiSavage.com - Print Page

SuzukiSavage.com
/cgi-bin/YaBB.pl
General Category >> Rubber Side Down! >> Another Starter Question
/cgi-bin/YaBB.pl?num=1268227865

Message started by prechermike on 03/10/10 at 05:31:05

Title: Another Starter Question
Post by prechermike on 03/10/10 at 05:31:05

When I start my bike, see signature currently about 9700 miles, I get a funny sound from the starter. I am not sure exaclty how to describe it, but here goes.

The bike starts fine, just a couple of seconds and it is ready to go. But it sounds like an extra loud clicking noise and something winding down coming from the starter.

I know the 80's bikes did not have some sort of anti reverse thing on the starter and am wondering if that is the problem. The bike starts and runs fine, the noise only lasts a couple of seconds, but I would like to figure this out. Any help would be greatly appreciated.

Thanks!

Title: Re: Another Starter Question
Post by verslagen1 on 03/10/10 at 11:36:35

Clicking could be a couple of things, the one way clutch making a bit of noise.

Or worse, some bit of metal bouncing around in there. I've heard some complain about loosing teeth off the starter gear.

I'd open it up and have a look.

Title: Re: Another Starter Question
Post by prechermike on 03/10/10 at 12:34:39

I have taken the starter off. I expected some sort of bendix, there was nothing. The starter felt fine, no wobble, no broken teeth, etc. Inside the case I did find one of the teeth on the starter gear (maybe) that had a little bit knocked off. I put it back together and it sounded a little better.

When I replaced the chain and tensioner I fished around in the bottom of the case with a magnet (ala Oldfeller) and found nothing, no gunk, sludge, nothing. The engine was making this noise before I did this work, in fact, that was the biggest reason I opened her up. I figured it was the chain or tensioner.

I looked on the microfiche and just could not figure out which gear was which, I tried starter and starter clutch, but was not smart enough to figure out where they went together.

Help me oh Savage gurus! Should I be getting another gear, will it hurt anything to keep riding?

Thanks!