SuzukiSavage.com - Print Page

SuzukiSavage.com
/cgi-bin/YaBB.pl
General Category >> Rubber Side Down! >> question..silver rod and small spring..
/cgi-bin/YaBB.pl?num=1243385858

Message started by 1988savage on 05/26/09 at 17:57:38

Title: question..silver rod and small spring..
Post by 1988savage on 05/26/09 at 17:57:38

about a 2inch silver looking rod and a small spring fell out of the side of the engine near the clutch. does anyone know where this goes and how to put it back?

Title: Re: question..silver rod and small spring..
Post by verslagen1 on 05/26/09 at 18:01:15

OOOOO
20 questions
I like 20 question

1.Do you have the clutch cover off

Title: Re: question..silver rod and small spring..
Post by 1988savage on 05/26/09 at 18:03:50

yes. but its not with me. my buddy is doin some stuff to it and i asked if he can fix it and he said he wud try to find where it goes. i figured if i asked on here someone might know

Title: Re: question..silver rod and small spring..
Post by Savage_Amusement on 05/26/09 at 18:13:23

If there is a cable attached to it, it would be the lever that actuates the clutch. Is the spring round with little hooks on it? Not real long, but bigger around.

http://www.yamahaoftroy.com/fiche_section_detail.asp?section=298932&category=Motorcycles&make=Suzuki&year=2005&fveh=7222

Any of that look like it?

Title: Re: question..silver rod and small spring..
Post by 1988savage on 05/26/09 at 18:24:16

the rod is number 22 in that diagram.. but the spring is reallly small. do u need to remove the clutch to replace that rod?

Title: Re: question..silver rod and small spring..
Post by Savage_Amusement on 05/26/09 at 18:27:34

I'm not really sure. I might just be a loose fit and slide back in. If the spring is not number 25 then I'm not fully sure where it goes.

Title: Re: question..silver rod and small spring..
Post by 1988savage on 05/26/09 at 18:29:06

hmm ok thanks

Title: Re: question..silver rod and small spring..
Post by verslagen1 on 05/26/09 at 18:54:30

What I was trying to get at was you didn't tell me alot.

The rod just slips into the center of the clutch.

Is this spring about the size of your little finger?

check the inside of the clutch cover is there a spring there?

Title: Re: question..silver rod and small spring..
Post by Yonuh Adisi on 05/26/09 at 19:27:20

http://www.bikebandit.com/assets/schematics/Suzuki/SU0145_016.gif

Title: Re: question..silver rod and small spring..
Post by 1988savage on 05/27/09 at 05:14:30

the rod is #22.. the spring is wayy smaller than my little finger... very mysterious

Title: Re: question..silver rod and small spring..
Post by serenity3743 on 05/27/09 at 05:18:26

Maybe the spring fell out of a fountain pen???!!!! ;)